Acer Aspire 1610 Series User Manual

							Acer Aspire 1610 Series
Service Guide
                                                                                                                                       PRINTED IN TAIWAN 
						

							II
Revision History
Please refer to the table below for the updates made on Aspire 1610 service guide.
Date Chapter Updates 
						

							III
Copyright
Copyright © 2004 by Acer Incorporated.   All  rights reserved.  No part of  this publication may be reproduced, 
transmitted, transcribed, stored in a retrieval system, or  translated into any language or computer language, in 
any form or by any means, electronic, mechanical, magne tic, optical, chemical, manual or otherwise, without 
the prior written permission  of Acer Incorporated.
Disclaimer
The information in this guide is  subject to change without notice.
Acer Incorporated makes no representations or warranties,  either expressed or implied, with respect to the 
contents hereof and specifically disclaims any warrantie s of merchantability or fitness for any particular 
purpose.  Any Acer Incorporated software described in this manual is sold or licensed as is.  Should the 
programs prove defective following their purchase, the bu yer (and not  Acer Incorporated, its distributor, or its 
dealer) assumes the entire cost of all necessary servicing, repair, and any incidental or consequential 
damages resulting from any defect in the software.  
Intel is a registered tradem ark of Intel Corporation.
Pentium and Pentium II/III are trademarks of Intel Corporation.
Other brand and product names are  trademarks and/or registered tradem arks of their respective holders. 
						

							IV
Conventions
The following conventions are used in this manual:
Screen messagesDenotes actual messages that appear 
on screen.
NOTEGives bits and pieces of additional 
information related to the current 
topic.
WARNINGAlerts you to any damage that might 
result from doing or not doing specific 
actions.
CAUTIONGives precautionary measures to 
avoid possible hardware or software 
problems.
IMPORTANTReminds you to do specific actions 
relevant to the accomplishment of 
procedures. 
						

							V
Preface
Before using this information and the product it supports, please read the following general information.
1.This Service Guide provides you with all technical information relating to the BASIC CONFIGURATION 
decided for Acer global product offering. To better fit local market requirements and enhance product 
competitiveness, your regional office MAY have decided to extend the functionality of a machine (e.g. 
add-on card, modem, or extra memory capability). These LOCALIZED FEATURES will NOT be covered 
in this generic service guide. In such cases, please contact your regional offices or the responsible 
personnel/channel to provide you with further technical details.
2.Please note WHEN ORDERING FRU PARTS, that you should check the most up-to-date information 
available on your regional web or channel. If,  for whatever reason, a part number change is made, it will 
not be noted in the printed Service Guide.  For ACER AUTHORIZED SERVICE PROVIDERS, your Acer 
office may have a DIFFERENT part number code to those given in the FRU list of this printed Service 
Guide. You MUST use the list provided by your regional Acer office to order FRU parts for repair and 
service of customer machines. 
						

							VI 
						

							VII
Table of Contents
Chapter 1 System Introduction                                                                       1
Features  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .  .1
System Block Diagram  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Board Layout   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 Top View  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Bottom View   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .  . .6
Front Panel  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Left Panel   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Right Panel  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Rear Panel   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Bottom Panel   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Indicators   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Indicator on cover  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
 Keyboard  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 Special keys   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
Hardware Specifications an d Configurations   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20
Chapter 2 System Utilities                                                                         \
    30
BIOS Setup Utility  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30
Navigating the BIOS Utility   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31
Information   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32
Main   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33
Advanced   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35
Security  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36
Boot . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40
Exit   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41
BIOS Flash Utility  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42
Chapter 3 Machine Disassem bly and Replacement  44
General Information   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45
Before You Begin   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45
Disassembly Procedure Flowchart  . . . . . . . . . . . .  . . . . . . . . . . . . . . . . . . . . . . . . . . .46
Removing the Battery  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48
Removing the Memory Module  . . . . . . . . . . . . . . .  . . . . . . . . . . . . . . . . . . . . . . . . . . .49
Removing the Modem Board   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50
Removing the Hard Disk Drive Module .  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51
Disassembling the Hard Disk Drive Module   . . . .  . . . . . . . . . . . . . . . . . . . . . . . .51
Removing the LCD Module . . . . . . . . . . . . . . . . .  . . . . . . . . . . . . . . . . . . . . . . . . . . . .52
Removing the Middle Cover  . . . . . . . . . . . . . .  . . . . . . . . . . . . . . . . . . . . . . . . . .52
Removing the Launch Board   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52
Removing the LCD Module  . . . . . . . . . . . . . . .  . . . . . . . . . . . . . . . . . . . . . . . . . .53
Disassembling the LCD Module  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55 Removing the LCD Bezel  . . . . . . . . . . . . . . . .  . . . . . . . . . . . . . . . . . . . . . . . . . .55
Removing the Inverter Board (15” L CD)  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55
Removing the 15” TFT LCD   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56
Removing the LCD Brackets  . . . . .  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .57
Removing the LCD Coaxial Cable   . . . . . . . . . .  . . . . . . . . . . . . . . . . . . . . . . . . .57
Removing the LCD Hinges  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58
Disassembling the Main Unit   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59 Removing the Keyboard  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59
Removing the RTC Battery  . . . . . . . . . . . . . . .  . . . . . . . . . . . . . . . . . . . . . . . . . .59
Removing the MimiPCI Card Plate  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59
Removing the Thermal Module  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60 
						

							VIII
Table of Contents
Removing the Processor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60
Installing the Processor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .61
Removing the Upper Case Assemly  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .61
Removing the Touchpad Board   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .62
Removing the Touchpad Cable   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .62
Removing the Floppy Disk Drive Module   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63
Dissembling the Floppy Disk Drive Module   . . . . . . . . . . . . . . . . . . . . . . . . . . . .63
Removing the VGA Heatsink Plate  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .64
Removing the CPU Heatsink Plate  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .64
Removing the ODD Module(1)   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65
Removing the ODD Module(2)   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65
Removing the HDD Bracket   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65
Removing the Main Board   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66
Removing the DC Board  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66
Removing the I/O Port Bracket  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67
Removing the PCMCIA Slot  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67
Removing the Speaker Set  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .68
System Upgrade Procedure  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .69
Base Unit to Wireless Unit   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .69
Assembling the Main Unit  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70
Installing the Speaker Set  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70
Installing the DC Board  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70
Installing the PCMCIA Slot   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70
Installing the Main Board   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70
Installing the HDD Bracket   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .71
Installing the ODD Module   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .71
Installing the CPU Heatsink Plate  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .  72
Installing the VGA Heatsink Plate  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .72
Installing the Floppy Disk Drive Module   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .73
Installing the Touchpad Cable   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .73
Installing the Touchpad Board   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .73
Installing the Upper Case Assemly  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Installing the Processor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75
Installing the Thermal Module  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75
Installing the MimiPCI Card Plate  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .76
Installing the RTC Battery  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77
Installing the Keyboard  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77
Assembling the LCD Module   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .79
Installing the LCD Hinges  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .79
Installing the LCD Coaxial Cable   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .79
Installing the LCD Brackets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .79
Installing the 15” TFT LCD   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80
Installing the Inverter Board (15” LCD)  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80
Installing the LCD Bezel  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .81
Installing the LCD Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .83
Installing the LCD Module  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .83
Installing the Launch Board   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .83
Installing the Middle Cover   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .84
Installing the Hard Disk Drive Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .86
Removing the Modem Board   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87
Installing the Memory Module  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .88
Installing the Battery  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .89
Chapter 4 Troubleshooting  90
System Check Procedures  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .91 
						

							IX
Table of Contents
External Diskette Drive Check   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .91
External CD-ROM Drive Check   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .91
Keyboard or Auxiliary Input Device Check   . . . . . . . . . . . . . . . . . . . . . . . . . . . . .91
Memory check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92
Power System Check  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92
Touchpad Check  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .94
Power-On Self-Test (POST) Error Message   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95
Index of Error Messages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96
Index of Symptom-to-FRU Error Message  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .99
Intermittent Problems  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .102
Undetermined Problems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .103
Chapter 5 Jumper and Connector Locations  104
Top View  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .104
Bottom View   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .106
Chappter 6 FRU (Field Replaceable Unit) List  107
Aspire 1610 Exploded Diagram   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108
Appendix A Model Definition and Configuration  117
Model Name Definition  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .117
Appendix B Test Compatible Components  119
Microsoft Windows XP Environment Test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .120
Appendix C Online Support Information  123
 Index  125 
						

							Chapter 11
Features
This computer was designed with the user in mind. Here are just a few of its many features:
Performance
TIntel® Pentium® 4  processor 3.06 GHz with 512 KB L2 cache
TTwo memory slots supporting 333 MHz DDR, upgradeable to 2GB
THigh-capacity, Enhanced-IDE hard disk
Display
T15.0” SXGA+ (1400X1050 resolution) TFT LCD panel provides a large viewing area for maximum 
efficiency and ease-of-use
T3D graphics support
TSupports simultaneous display between LCD and CRT display
TS-video for out put toa television or display device that supports S-video input
T“Automatic LCD dim” feature that automatically selects the best setting for the display in order to 
conserve power
TDualViewTM support
Multimedia
THigh-speed built-in optical drive: DVD-Dual
TMS DirectSound compatible
TBuilt-in dual speakers
TAudio ports for microphone-in and headphones
Connectivity
TIntegrated 10/100 Mbps Ethernet connection
TBuilt-in 56Kbps fax/data modem
TFour universal serial bus (USB)2.0 ports
TOne IEEE 1394 port
TIEEE 802.11g
Expansion
TPC card slot enableing a range of add-on options
TUpgradeable hard disk and memory modules
I/O Ports
TTwo Type II or one Type III PC CardBus (PCMCIA) slot
TOne IEEE 1394 port
TOne FIR port
TOne RJ-11 modem jack (V.90/V.92, 56K)
System IntroductionChapter 1