Aimco Brakes MSDSHammer Case Oil User Manual

							
 
 
 
Chevron Material Safety Data Sheet 
DISCONTINUED  -  See Section 16. 
 
 
 
 
CHEVRON NL Gear Compound 150                                  CPS255053 
                                                             Page   1 of\
 6 
 
 
 
 
 
 
 
This Material Safety Data Sheet contains environmental, health and 
toxicology information for your employees.  Please make sure this 
information is given to them.  It also contains information to help 
you meet community right-to-know/emergency response reporting 
requirements under SARA Title III and many other laws.  If you resell 
this product, this MSDS must be given to the buyer or the information 
incorporated in your MSDS.  Discard any previous edition of this MSDS. 
 
PRODUCT DISCONTINUED. This MSDS will no longer be updated. 
 
________________________________________________________________________\
__________ 
 
 1. PRODUCT IDENTIFICATION 
________________________________________________________________________\
__________ 
 
CHEVRON NL Gear Compound 150 
 
         - A HAZARD WARNING IS NOT REQUIRED FOR THIS PRODUCT UNDER 
           OSHA HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200) 
 
PRODUCT NUMBER(S): CPS255053 
PRODUCT INFORMATION: (800)582-3835 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
Revision Number: 9        Revision Date: 03/20/92      MSDS Number: 0003\
37 
            NDA - No Data Available      NA - Not Applicable 
 
Prepared According to the OSHA Hazard Communication 
Standard (29 CFR 1910.1200) by the Chevron Environmental 
Health Center, Inc., P.O. Box 4054, Richmond, CA  94804.  
						

							
 
 
CHEVRON NL Gear Compound 150                                 Page   2 of\
 6 
 
________________________________________________________________________\
__________ 
 
 2. FIRST AID-EMERGENCY PH. (800)457-2022/(510)233-3737 (24 HR) 
________________________________________________________________________\
__________ 
 
EYE CONTACT: 
No first aid procedures are required.  However, as a precaution flush ey\
es 
with fresh water for 15 minutes.  Remove contact lenses if worn. 
SKIN CONTACT: 
No first aid procedures are required.  As a precaution, wash skin 
thoroughly with soap and water.  Remove and wash contaminated clothing. 
INHALATION: 
Since this material is not expected to be an immediate inhalation proble\
m, 
no first aid procedures are required. 
INGESTION: 
If swallowed, give water or milk to drink and telephone for medical 
advice.  Consult medical personnel before inducing vomiting. If medical 
advice cannot be obtained, then take the person and product container to\
 
the nearest medical emergency treatment center or hospital. 
________________________________________________________________________\
__________ 
 
 3. IMMEDIATE HEALTH EFFECTS - (ALSO SEE SECTIONS 11 & 12) 
________________________________________________________________________\
__________ 
 
EYE CONTACT: 
This substance is not expected to cause prolonged or significant eye 
irritation.  This hazard evaluation is based on the data from similar 
materials. 
SKIN IRRITATION: 
This substance is not expected to cause prolonged or significant skin 
irritation.  This hazard evaluation is based on data from similar 
materials. 
DERMAL TOXICITY: 
The systemic toxicity of this substance has not been determined.  Howeve\
r, 
it should be practically non-toxic to internal organs if it gets on the 
skin.  This hazard evaluation is based on data from similar materials. 
RESPIRATORY/INHALATION: 
The systemic toxicity of this substance has not been determined.  Howeve\
r, 
it should be practically non-toxic to internal organs if inhaled.  This 
hazard evaluation is based on data from similar materials. 
INGESTION: 
The systemic toxicity of this substance has not been determined.  Howeve\
r, 
it should be practically non-toxic to internal organs if swallowed.  Thi\
s 
hazard evaluation is based on data from similar materials. 
________________________________________________________________________\
__________ 
 
 4. PROTECTIVE EQUIPMENT 
________________________________________________________________________\
__________ 
 
EYE PROTECTION: 
No special eye protection is usually necessary. 
SKIN PROTECTION: 
No special skin protection is usually necessary.  Avoid prolonged or 
frequently repeated skin contact with this material.  Skin contact can b\
e 
 
Revision Number: 9        Revision Date: 03/20/92      MSDS Number: 0003\
37 
            NDA - No Data Available      NA - Not Applicable  
						

							
 
 
CHEVRON NL Gear Compound 150                                 Page   3 of\
 6 
 
minimized by wearing protective clothing. 
RESPIRATORY PROTECTION: 
No special respiratory protection is normally required.  However, if 
operating conditions create airborne concentrations which exceed the 
recommended exposure standards, the use of an approved respirator is 
required. 
VENTILATION: 
Use adequate ventilation to keep the airborne concentrations of this 
material below the recommended exposure standard. 
________________________________________________________________________\
__________ 
 
 5. FIRE PROTECTION 
________________________________________________________________________\
__________ 
 
FLASH POINT: (COC) 399F  (204C) Min. 
AUTOIGNITION: NDA 
FLAMMABILITY LIMITS (% by volume in air):  Lower: NA  Upper: NA 
EXTINGUISHING MEDIA: 
   CO2, Dry Chemical, Foam and Water Fog. 
NFPA RATINGS: Health 0; Flammability 1; Reactivity 0; Special NDA; 
HMIS RATINGS: Health 0; Flammability 1; Reactivity 0; Other NDA; 
(Least-0, Slight-1, Moderate-2, High-3, Extreme-4).  These values are 
obtained using the guidelines or published evaluations prepared by the 
National Fire Protection Association or, if applicable, the National 
Paint and Coating Association, and do not necessarily reflect the hazard\
 
evaluation of the Chevron Environmental Health Center.  Read the entire 
document and label before using this product. 
FIRE FIGHTING PROCEDURES: 
For fires involving this material, do not enter any enclosed or confined\
 
fire space without proper protective equipment, including self-contained\
 
breathing apparatus. 
COMBUSTION PRODUCTS: 
Normal combustion forms carbon dioxide, water vapor and may produce oxid\
es 
of sulfur, nitrogen and phosphorous.  Incomplete combustion can produce 
carbon monoxide. 
________________________________________________________________________\
__________ 
 
 6. STORAGE, HANDLING, AND REACTIVITY 
________________________________________________________________________\
__________ 
 
HAZARDOUS DECOMPOSITION PRODUCTS: 
NDA 
STABILITY: 
Stable. 
HAZARDOUS POLYMERIZATION: 
Polymerization will not occur. 
INCOMPATIBILITY: 
May react with strong oxidizing agents, such as chlorates, nitrates, 
peroxides, etc. 
SPECIAL PRECAUTIONS: 
DO NOT weld, heat or drill container.  Residue may ignite with explosive\
 
violence if heated sufficiently.  CAUTION!  Do not use pressure to empty\
 
drum or explosion may result. 
 
 
Revision Number: 9        Revision Date: 03/20/92      MSDS Number: 0003\
37 
            NDA - No Data Available      NA - Not Applicable  
						

							
 
 
CHEVRON NL Gear Compound 150                                 Page   4 of\
 6 
 
________________________________________________________________________\
__________ 
 
 7. PHYSICAL PROPERTIES 
________________________________________________________________________\
__________ 
 
SOLUBILITY: Soluble in hydrocarbon solvents; insoluble in water. 
APPEARANCE: Dark green viscous liquid. 
BOILING POINT: NA 
MELTING POINT: NA 
EVAPORATION: NA 
SPECIFIC GRAVITY: 0.89  @ 15.6/15.6C 
VAPOR PRESSURE: NA 
PERCENT VOLATILE (VOLUME %): NA 
VAPOR DENSITY (AIR=1): NA 
VISCOSITY: 141  cSt @ 40C 
________________________________________________________________________\
__________ 
 
 8. ENVIRONMENTAL CONCERNS, SPILL RESPONSE AND DISPOSAL 
________________________________________________________________________\
__________ 
 
CHEMTREC EMERGENCY PH. (800)424-9300/(202)483-7616 (24 hr) 
SPILL/LEAK PRECAUTIONS: 
This material is not expected to present any environmental problems othe\
r 
than those associated with oil spills. 
 
Stop the source of the leak or release.  Clean up releases as soon as 
possible.  Contain liquid to prevent further contamination of soil, 
surface water or groundwater.  Clean up small spills using appropriate 
techniques such as sorbent materials or pumping.  Where feasible and 
appropriate, remove contaminated soil.  Follow prescribed procedures for\
 
reporting and responding to larger releases. 
DISPOSAL METHODS: 
Place contaminated materials in disposable containers and dispose of in \
a 
manner consistent with applicable regulations.  Contact local 
environmental or health authorities for approved disposal of this 
material. 
 
 
________________________________________________________________________\
__________ 
 
 9. EXPOSURE STANDARDS, REGULATORY LIMITS AND COMPOSITION 
________________________________________________________________________\
__________ 
 
COMPOSITION COMMENT: 
All the components of this material are on the Toxic Substances Control 
Act Chemical Substances Inventory. 
 
This product fits the ACGIH definition for mineral oil mist.  The ACGIH 
TLV is 5 mg/m3, the OSHA PEL is 5 mg/m3. 
 
The percent compositions are given to allow for the various ranges of 
the components present in the whole product and may not equal 100%. 
 
PERCENT/CAS#  COMPONENT/REGULATORY LIMITS 
 
Revision Number: 9        Revision Date: 03/20/92      MSDS Number: 0003\
37 
            NDA - No Data Available      NA - Not Applicable  
						

							
 
 
CHEVRON NL Gear Compound 150                                 Page   5 of\
 6 
 
 
  100.0 %     CHEVRON NL Gear Compound 150 
 
  CONTAINING 
 
>  97.0 %     LUBRICATING BASE OIL 
              5 mg/m3 mist ACGIH TLV 
              10 mg/m3 mist ACGIH STEL 
              5 mg/m3 mist OSHA TWA 
 
The BASE OIL may be a mixture of any of the following: CAS 64741884, 
CAS 64741895,CAS 64741964,CAS 64741975,CAS 64742014,CAS 64742525, 
CAS 64742536,CAS 64742547,CAS 64742627,CAS 64742650,CAS 72623837. 
 
<   3.0 %     ADDITIVES 
 
TLV  - Threshold Limit Value        TWA - Time Weighted Average 
STEL - Short-term Exposure Limit    TPQ - Threshold Planning Quantity 
RQ   - Reportable Quantity          CPS - CUSA Product Code 
CC   - Chevron Chemical Company     CAS - Chemical Abstract Service Numb\
er 
________________________________________________________________________\
__________ 
 
10. REGULATORY INFORMATION 
________________________________________________________________________\
__________ 
 
DOT SHIPPING NAME: NOT DESIGNATED AS A HAZARDOUS MATERIAL BY THE 
                   FEDERAL DOT 
DOT HAZARD CLASS: NOT APPLICABLE 
DOT IDENTIFICATION NUMBER: NOT APPLICABLE 
 
SARA 311 CATEGORIES:     1.   Immediate (Acute) Health Effects; NO 
                         2.   Delayed (Chronic) Health Effects; NO 
                         3.                        Fire Hazard; NO 
                         4.  Sudden Release of Pressure Hazard; NO 
                         5.                  Reactivity Hazard; NO 
 
The following components of this material are found on the regulatory 
lists indicated by the number below the component name: 
 
LUBRICATING BASE OIL 
  is found on lists:  14,15,17, 
 
REGULATORY LISTS SEARCHED: 
 
01=SARA 313             02=MASS RTK             03=NTP Carcinogen 
04=CA Prop. 65          05=MI 406               06=IARC Group 1 
07=IARC Group 2A        08=IARC Group 2B        09=SARA 302/304 
10=PA RTK               11=NJ RTK               12=CERCLA 302.4 
13=MN RTK               14=ACGIH TLV            15=ACGIH STEL 
16=ACGIH Calculated TLV 17=OSHA TWA             18=OSHA STEL 
19=Chevron TLV          20=EPA Carcinogen       21=TSCA Sect 4(e) 
22=TSCA Sect 5(a)(e)(f) 23=TSCA Sect 6          24=TSCA Sect 12(b\
) 
25=TSCA Sect 8(a)       26=TSCA Sect 8(d)       28=Canadian WHMIS 
29=OSHA CEILING 
 
Revision Number: 9        Revision Date: 03/20/92      MSDS Number: 0003\
37 
            NDA - No Data Available      NA - Not Applicable  
						

							
 
 
CHEVRON NL Gear Compound 150                                 Page   6 of\
 6 
 
________________________________________________________________________\
__________ 
 
11. PRODUCT TOXICOLOGY DATA 
________________________________________________________________________\
__________ 
 
EYE IRRITATION: 
No product toxicology data available.  The hazard evaluation was based o\
n 
data from similar materials. 
SKIN IRRITATION: 
No product toxicology data available.  The hazard evaluation was based o\
n 
data from similar materials. 
DERMAL TOXICITY: 
No product toxicology data available.  The hazard evaluation was based o\
n 
data from similar materials. 
RESPIRATORY/INHALATION: 
No product toxicology data available.  The hazard evaluation was based o\
n 
data from similar materials. 
INGESTION: 
No product toxicology data available.  The hazard evaluation was based o\
n 
data from similar materials. 
________________________________________________________________________\
__________ 
 
12. ADDITIONAL HEALTH DATA 
________________________________________________________________________\
__________ 
 
ADDITIONAL HEALTH DATA COMMENT: 
This product contains petroleum base oils which may be refined by variou\
s 
processes including severe solvent extraction, severe hydrocracking, or 
severe hydrotreating.  None of the oils requires a cancer warning under 
the OSHA Hazard Communication Standard (29 CFR 1910.1200).  These oils\
 
have not been listed in the National Toxicology Program (NTP) Annual 
Report nor have they been classified by the International Agency for 
Research on Cancer (IARC) as; carcinogenic to humans (Group 1), prob\
ably 
carcinogenic to humans (Group 2A), or possibly carcinogenic to humans 
(Group 2B). 
 
________________________________________________________________________\
__________ 
 
********************************************************************** 
________________________________________________________________________\
__________ 
 
The above information is based on the data of which we are aware and is 
believed to be correct as of the date hereof.  Since this information ma\
y 
be applied under conditions beyond our control and with which we may be 
unfamiliar and since data made available subsequent to the date hereof m\
ay 
suggest modification of the information, we do not assume any responsibi\
l- 
ity for the results of its use.  This information is furnished upon 
condition that the person receiving it shall make his own determination 
of the suitability of the material for his particular purpose. 
 
 
 
 
 
 
Revision Number: 9        Revision Date: 03/20/92      MSDS Number: 0003\
37 
            NDA - No Data Available      NA - Not Applicable