Data Delivery Devices VHF, UHF & ISM Wireless RTU RFScada 8ADI-9DO 4ADI-5DO User Manual

RFScada 8ADI-9DO/4ADI-5DO Manual Ver 3.6 Copyright ©2005 Data Delivery Devices LLC Page - 11 – Bartlesville OK Tel 918-335-3318      FAX 918-398-9990  

RFScada 8ADI-9DO/4ADI-5DO Manual Ver 3.6 Copyright ©2005 Data Delivery Devices LLC Page - 13 – Bartlesville OK Tel 918-335-3318      FAX 918-398-9990 
Device Unpacking, Verification and Permanent Installation. 
Unpacking: 
First carefully unpack the units and verify all the contents are complete, intact and match the items 
ordered. If there is any discrepancy then please contact Data Delivery Devices LLC for assistance. 
  
Quantity  Standard Contents (for one RFScada unit) 
4ADI-5DO 8ADI-9DO...

RFScada 8ADI-9DO/4ADI-5DO Manual Ver 3.6 Copyright ©2005 Data Delivery Devices LLC Page - 14 – Bartlesville OK Tel 918-335-3318      FAX 918-398-9990 
device transmits data, and the red LED illuminates each time the unit receives data. If the ‘Transmit’ 
LED and ‘Receive’ LED flash in rapid succession (normal operation) then this device is successfully 
communicating with another device. For this to occur the main board, including the transmitters and 
receivers on each unit must all be operating...

RFScada 8ADI-9DO/4ADI-5DO Manual Ver 3.6 Copyright ©2005 Data Delivery Devices LLC Page - 15 – Bartlesville OK Tel 918-335-3318      FAX 918-398-9990 
Once the panel has been removed from the cabinet, drill holes large enough (commonly 
available ‘step’ drills are very useful for these size holes) for the cable clamps or conduit fittings and 
install the clamps tightly. Remove any dust or particles remaining from drilling, then replace the panel 
in the cabinet and complete wiring of the inputs, outputs...

RFScada 8ADI-9DO/4ADI-5DO Manual Ver 3.6 Copyright ©2005 Data Delivery Devices LLC Page - 16 – Bartlesville OK Tel 918-335-3318      FAX 918-398-9990 
Typical Wiring Installation – 8ADI-9DO (shown with ISM & AO8 Options) 
 
 
 
  

RFScada 8ADI-9DO/4ADI-5DO Manual Ver 3.6 Copyright ©2005 Data Delivery Devices LLC Page - 17 – Bartlesville OK Tel 918-335-3318      FAX 918-398-9990 
Component Identification, Signal and Wiring Reference. 
 
8ADI-9DO Component / Connection Identification  
 
 
 
 
RS-232
ModBus
Install jumpe
rfor RS-485RS-485 
Modbus
GND
Chan 1-4 
4-20 mA In
 
Chan 5-8
4-20mA InChan 1-4
Switch InputsChan 5-8 
Switch 
Gnd 
4-20mA Transducer 
+ve supply 
Relay 8 no
nc
nc
nc
nc
nc
nc nc
no
no
no
no
no
no com
com 
com 
com...

RFScada 8ADI-9DO/4ADI-5DO Manual Ver 3.6 Copyright ©2005 Data Delivery Devices LLC Page - 18 – Bartlesville OK Tel 918-335-3318      FAX 918-398-9990 
4ADI-5DO Component / Connection Identification 
 
 
 
 
  

RFScada 8ADI-9DO/4ADI-5DO Manual Ver 3.6 Copyright ©2005 Data Delivery Devices LLC Page - 19 – Bartlesville OK Tel 918-335-3318      FAX 918-398-9990 
 
RS-232  2-3     RS-485  1-2 
Install 
Pin 1 
Normal Operation  1-2     Power Save (relay disabled)  2-3 
     Install jumper for system relay 
Pin 1 
1 
     DC Power      AC Power 
     AC Line Power Fuse 
     DC Power Fuse  
     Radio Transceiver or Interface Option Board 
RS-232 Connection     RS-485 Connections     
GND A B 
  System / Modbus LED...

RFScada 8ADI-9DO/4ADI-5DO Manual Ver 3.6 Copyright ©2005 Data Delivery Devices LLC Page - 20 – Bartlesville OK Tel 918-335-3318      FAX 918-398-9990 
 
The following chart lists the connections and basic functions of all pins. Refer to the detailed notes for 
an explanation of each function. Items marked ‘*’ are on the 8ADI-9DO only and do not apply to the 
4ADI-5DO. Note that the connector nomenclature is the same for both boards, for example J1 is the 
AC power connection on both the 4ADI-5DO and the...