European American Armory Over And Under Double Rifle Izh94 Servis Instructions Manual

							1 IZH94 Sever
OVER & UNDER COM-
BINATION
RIFLE/SHOTGUN
WARNING AND
INSTRUCTION MANUALEuropean American Armory Corp.
3855 North U.S. Highway One
Cocoa, Florida 32926
(321) 639-4842
www.eaacorp.com
E-mail: [email protected]
© Copyright EAA Corp. 1/01 
						

							2 Additional information on
screw choke tubes:
A)Before working with screw choke tubes make sure the gun is completely
unloaded.
B) Only tighten or loosen choke tubes with flat key wrench supplied with shotgun.
Note: wrench (and extra choke tube or tubes if supplied) are under the
cardboard in front of the shotgun receiver in the box.
C)Never shoot the shotgun with a partially installed choke tube.
D)For steel shot or slugs use IC or Cylinder choke tubes. If you gun has choke
tubes that protrude out the barrel and are checkered on the outside area that
protrudes in front of the barrel, these are steel shot choke tubes and the IC
or Cylinder note does not apply for the steel shot. The IC or Cylinder choke
tubes are the only tubes that can be used with slugs.
F)Correctly installed choke tubes: Lead shot choke tubes should fit flush or
slightly below the muzzle end of the barrel, Steel shot choke will protrude out
from the barrel about 3/4 or so and the mating lip will be flush with barrel
end.
G)Before using the shotgun make sure that the choke tubes are installed
correctly: 1) make sure the gun is unloaded 2) look into the barrel from the
muzzle end and you should see a ring at the junction of the barrel and the tube.
The ring that you will see is caused by the barrel not the tube. IE: If you see
the tube and not the barrel ring, then the tube is either installed too tight or
damaged. What you want to see at the junction of the barrel and tube, is the
tube edge below the barrel. You may also use your finger to feel that the barrel
is above the tube at the junction... Careful that your finger does not become
stuck in the tube. Check your choke tube after each use or every 100 rounds.
H)Keep choke tubes lubricated and installed. Never fire the gun without a choke
tube installed. Handle choke tubes carefully since the leading edge is very
thin. 
						

							3 EAA MODEL: IZH94 “Sever”
COMBINATION RIFLE / SHOTGUN
WARNING AND INSTRUCTION MANUAL
PLEASE READ THESE INSTRUCTIONS
MODEL NUMBERBARREL LENGTHGAUGES
IZH94-“Sever”2420GA/3”
CALIBERSFINISH
22LR, 22WRMBLUE
GENERAL INFORMATION:
Weight (average) - 24 = 7.7 Lbs.
Overall Length - 41.33
FOR YOUR SAFETY AND THE SAFETY OF OTHERS, this owner’s manual
contains important warnings and safety procedures which must be understood
BEFORE using this firearm.  Read the entire manual and if you do not
understand any part of it or the operation of your Combination Rifle / Shotgun,
stop and seek professional firearms instructions.  You can get a copy of this
manual from European American Armory Corp. on request.
Record the serial number of your firearm:
#_________________________________________________________________________
and a description of it:
__________________________________________________________________________
Make a copy of this manual, proof of purchase/sales record for safekeeping in
a secure safe or fireproof container.  Such proof is necessary if the firearm is
stolen or for warranty repair.  Before handling any firearm, make sure you know
the safety procedures and most importantly, keep the firearm pointed in a safe
direction.
W A R N I N G
**YOU RISK INJURY OR DEATH BY HANDLING THIS FIREARM**
Before handling this firearm, read, understand and follow the instructions in this
manual.  Always keep this manual with the firearm.  If you lend, give or sell this
firearm, be sure the manual goes with it.  If there is anything you do not
understand, seek advice from someone qualified in safe handling of firearms.
W A R N I N G
*This firearm should always be transported and stored unloaded in its case.* 
						

							4 Type Of Ammunition To Be Used:
It is suggested that high quality commercially manufactured ammunition be
used in this firearm.  Some factory ammunition works better than others and
you should stick with the brand you find works well in your Combination Rifle
/ Shotgun.  Avoid military surplus or hot loaded ammo.  The use of reloaded,high pressure or hand loaded ammunition will void the warranty.
N O T I C E
COMBINATION RIFLE / SHOTGUN ARE CLASSIFIED AS FIREARMS OR
DANGEROUS WEAPONS and are sold by European American Armory
Corporation with the specific understanding that we are not responsible in any
manner what-so-ever for their safe handling or resale under local laws and
regulations.
European American Armory shall not be responsible in any manner
whatsoever for malfunctioning of the firearm, for physical injury or for property
damage resulting in whole or in part from (1) intentional or negligent discharge,
(2) improper or careless handling, (3) unauthorized modifications and/or
alteration to the internal/safety mechanisms, (4) defective, improper, high
pressure, hand-loaded, or reloaded ammunition, (5) corrosion and/or lack of
proper maintenance (6) neglect, or (7) other influences beyond our direct and
immediate control.  This limitation applies regardless of whether liability is
asserted on the basis of contract, negligence or strict liability (including any
failure to warn).  Under no circumstance shall European American Armory
Corporation be liable for incidental or consequential damages, such as loss of
use of property, commercial loss and loss of earnings or profits.
Safety Procedures:
1.  We recommend that you get competent firearms instruction in safe handling
before using this firearm.  Please ask your dealer. All guns are extremely
dangerous if carelessly handled or used.  Remember that the firearm user is the
primary “safety” and to depend on any mechanical devices is to be only half
safe.
2.  This firearm will fire if a cartridge is in a chamber and the trigger is pulled and
the safety is disengaged.
3.  DO NOT LOAD THIS COMBINATION RIFLE / SHOTGUN UNTIL YOU
UNDERSTAND HOW THIS COMBINATION RIFLE / SHOTGUN OPERATES.
KEEP this Combination Rifle / Shotgun unloaded at all times except when ready
to fire and you are sure of your target.
4.  ALWAYS carry this Combination Rifle / Shotgun in a case or original box
unloaded.5.  NEVER point this Combination Rifle / Shotgun at anything that is not your
intended target even if this Combination Rifle / Shotgun is unloaded.  When
loading, cleaning, unloading or handling, always be sure the muzzle is pointed 
						

							5 in a safe direction and always keep your finger off the trigger.
6.  NEVER assume any gun is unloaded.  Before handling, check to make sure
the chamber is empty.  See unloading Instructions and then unload any
ammunition.  Make sure you know that this or any firearm is fully unloaded
before displaying or handling it.  When handling any firearm, keep your fingers
away from the trigger at all times until you intend to fire.
7.  WARNING: The actual firearm does not contain any lead; however, it does
fire ammunition containing lead or lead compounds known to the State of
California to cause cancer, birth defects, reproductive toxicity, and other
serious physical injury.  Those who discharge a firearm, stand near someone
who discharges a firearm or cleans firearms are hereby warned of the dangers
presented by lead and lead compounds and should take protective health
measures.  Avoid exposure to lead while handling and wash your hands after
contact.  Proper air ventilation is absolutely necessary when shooting indoors.
A M M U N I T I O N   W A R N I N G
Old, Hot-loaded and/or re-loaded ammunition may be dangerous.  Because of
the poor or nonexistent quality control standards among some companies or
people who make reloaded ammunition and the dangers of overloads and
under loads (squib loads) which may occur, we recommend that only good
quality new factory ammunition be fired in our firearms.  [If you prepare your
own hand loads, do NOT exceed recommended pressures in line with those
generated by standard factory loads as manufactured by Remington,
Winchester, Federal, PMC or other reputable companies.]  Old ammunition
may not fire with sufficient force to expel the projectile from the barrel.
READING THESE SAFETY RULES WILL SAVE
YOUR LIFE OR  THE LIFE OF SOMEONE ELSE
Get instructions from a competent firearms instructor before using this or any
firearm.  Learn from a professional how to handle, load, unload, operate, fire
and care for your gun.
NEVER PLAY with your firearm.  It is not a toy and can be a very dangerous
weapon that can cause serious personal injury or death.
Always keep the gun pointed in a safe direction.  Treat every gun as if it is
loaded...all the time.  NEVER point any firearm (loaded or unloaded) at any
person or anything you do not intend to shoot.  Always keep your gun unloaded
until ready to use and make sure that it is unloaded before cleaning.
Keep your finger OFF the trigger until you are actually aiming at the target and
ready to shoot.  Learn to rest your finger outside of the trigger guard.
Never rely on a gun’s “safety” to protect you from unsafe gun handling.  A safety
is only a mechanical device, not a substitute for common sense and gun safety
procedures.
Never leave a gun unattended or where it could fall and fire. 
						

							6 READING THESE SAFETY RULES WILL SAVE
YOUR LIFE OR  THE LIFE OF SOMEONE ELSE
Store guns and ammunition separately beyond the reach of children. Make sure
that they are properly secured so untrained individuals and children will be denied
access to your guns and ammo.
Test your gun’s operation and safeties only at a shooting range while the
firearm is pointed in a safe direction.
Know your target and what is beyond.  Ask yourself what your bullet will hit if it
misses the target or passes through the intended target.  Remember, a fired
projectile can travel over a mile (including a ricochet) and is capable of going
through walls.
Guns and alcohol or drugs do not mix.  Don’t take any alcoholic beverages and/
or drugs before or during shooting activities.
Never pull a gun toward you by the muzzle.  Don’t climb a tree, cross a ditch or
fence with a loaded gun.
Always empty guns before entering a house, car, truck, boat, RV, camp or any
building.
When receiving a gun, always open the action and check to make sure the
chamber is unloaded.
NEVER accept anyone’s word that a gun is “unloaded” or “empty”.  You should
immediately open the action and check to make sure it is unloaded.
Be careful with ALL ammunition.  Even “blank” cartridges are deadly at close
range due to the muzzle blast.  Make sure your ammunition is in new and in
good clean condition.  Do NOT oil or grease ammo as this may damage the
cartridge primer.  Do NOT tamper with or alter the standard factory ammunition.
Keep firearms unloaded when not actually in use.  Load the gun only when on
the range preparing to fire and unload it before leaving the range.
Never put your hand over the muzzle of a gun.
ALWAYS WEAR protective shooting glasses and hearing protection when
using firearms.
Spectators should be at least 10 feet behind and away from the shooter while
the shooter is loading, shooting and unloading.  Spectators should wear
protection for hearing and sight loss and they should avoid distracting those
shooting their firearms.
Never drop your gun.  If you do drop it, unload it and check it for proper function
before using it again.
Do NOT alter or modify your gun.  Don’t try to change your gun’s trigger pull,
because it may affect sear engagement and thereby cause accidental firing.
Do NOT remove any internal safety or safety device on the firearm.  Safety
mechanisms are designed to protect you from injury or death. 
						

							7 READING THESE SAFETY RULES WILL SAVE
YOUR LIFE OR  THE LIFE OF SOMEONE ELSE
Do maintain and keep your gun clean.  Keep in a dry place away from other metals
and water.  If your gun shows sign of corrosion or improper operation, have it
serviced by a competent gunsmith.
Keep the muzzle pointed in a safe direction when loading and unloading your
gun.  Never point the muzzle at anyone.
Never shoot at hard flat surfaces or water....bullets ricochet.
If a gun fails to fire when the trigger is pulled, keep it pointed down range at the
target for 60 seconds.  Sometimes slow primer ignition will cause a “hang fire”
and the cartridge will go off after a short pause.  If it still fails to fire, keep muzzle
pointed in safe direction and avoid exposure to the breech, as you attempt to
unload your firearm.
Never let water, snow, mud or other material enter the barrel. Always be sure
the barrel is free of any obstruction.
the correct ammunition for your gun.  Do NOT use the wrong size or wrong
strength ammunition in your firearm.
Repeated and prolonged exposure to gunfire may cause toxic levels of lead in
your body.  High levels of lead in the blood may result in cancer, impotency,
birth defects and other serious physical injury.  When shooting indoors, make
sure there is proper fresh air ventilation.
Teach children: 1. NOT to touch guns, bullets, cartridges, shells, flares or any
explosive device and 2. If they discovery such a dangerous item or weapon,
they must immediately report its location to their parents, school teacher or police.
Remember a firearm has the capability of taking your life or the life of someone
else.  Be careful with your firearm -- an accident is almost always the result of
not following basic safety rules.
HOME SAFETY IS PROBABLY YOUR BIGGEST CONCERN.  We suggest a gun
lock such as Master Gun Locks.  They work on most firearms and are available
in gun shops and sporting goods departments.  For more information write:
Master Gun Locks; Master Lock Company, P.O. Box 10367, Milwaukee. WI
53210.  You have invested this much in your new firearm, now invest a little
more in your family’s safety.
USED FIREARMS - If you got your European American Armory firearm as a
used gun, BEFORE USING IT you should unload it and check all its functions
to be sure it works correctly. Firearms are sometimes altered to work
incorrectly, or parts may be removed, lost or replaced with incorrect parts. First,
unload it and check it yourself and then take it to a good gunsmith who knows
European American Armory firearms, and have him examine it.
WRITE US concerning any items or circumstances which you don’t understand
and which might relate to your safety and the operation of your firearm. 
						

							8 W A R N I N G
BEFORE LOADING or firing a Combination Rifle / Shotgun, examine the bore
and the firing chamber to be certain they are clean and free of any obstruction.
Even a heavy coat of oil, grease, snow or water may result in damage to the
firearm and injury to the shooter and/or persons near the firearm.  A misfire or
unusual sound upon firing is a signal to cease firing and to examine the
chamber and bore.  If there is any obstruction, clear the obstruction and clean
the bore and chamber before firing.
F I R I N G  W A R N I N G
When shooting, full eye and ear protection is mandatory at all times.  Shooters
and spectators must wear shooting glasses and sound suppressor to prevent
eye injury and hearing loss.  Vision loss and hearing impairment can occur
with only one moment of non-protection.
W A R N I N G
Any bore obstruction, even if it is only partly blocked, may cause the gun to
blow up if it is fired, or may cause damage to the gun such as a bulged barrel.
To avoid injury or death to the shooter or bystanders, check the barrel before
shooting or if a shot does not sound normal.
W A R N I N G
Always keep the muzzle pointed in a safe direction!  Never attempt to load or
unload any firearm inside a vehicle, building or other confined space (except a
properly constructed shooting range).  Enclosed areas frequently offer no
completely safe direction in which to point the firearm.  If an accidental
discharge occurs, there is great risk of injury or property damage.  Before
loading, always clean all, grease and oil from the bore and chamber, and check
to be certain that no obstruction is in the barrel.  Any foreign matter in the barrel
could result in a bulged or burst barrel or other damage to the firearm and could
cause serious injury to the shooter or to others.
W A R N I N G
If there is any reason to suspect that a bullet or projectile is obstructing the
barrel, immediately unload the firearm (See Unloading Instructions) and check
the chamber and the bore.  A bullet may be lodged some distance down the
barrel where it can not easily be seen.  Check the bore by using a cleaning rod
to pass through the barrel.  If a blockage is in the bore, DO NOT ATTEMPT TO
SHOOT IT OUT WITH ANOTHER CARTRIDGE, OR BLOW IT OUT WITH A
BLANK CARTRIDGE OR A CARTRIDGE FROM WHICH THE BULLET HAS
BEEN REMOVED.  SUCH TECHNIQUE(S) CAN GENERATE EXCESSIVE
PRESSURE, DAMAGE THE FIREARM AND CAUSE SERIOUS PERSONAL
INJURY.  If the blockage can be removed with a cleaning rod, clean any
unburned powder grains from the bore, chambers & mechanism before
resuming shooting.  If the blockage can not be dislodged by tapping it with a
cleaning rod, take the firearm to a gunsmith. 
						

							9 WARNING (Mechanical Malfunctions)
STOP SHOOTING IMMEDIATELY AND UNLOAD YOUR FIREARM if your
firearm develops: a mechanical malfunction; binding or stoppage; spitting
powder/gas; a cartridge primer is punctured; a cartridge case is bulged or
ruptured; or the sound on firing does not sound quite right.  Do NOT try one
more shot but unload your firearm and take it and the ammunition to a qualified
gunsmith or send it back to EAA for examination.  Do not assume that the
Combination Rifle / Shotgun is empty merely because you checked the chamber.
You must also check the bore for any fired shot or wad jammed inside the barrel.
EXTERNAL CONTROL PARTS:
Trigger Block Safety : Located on the receiver tang behind the top lever, slide
button style. When the Red Dot is showing the Combination Rifle / Shotgun will
fire when the trigger is pulled!! Do not disengage safety unless you are ready
to fire the Combination Rifle / Shotgun. (Safety Engaged - The Red Dot covered
and the trigger is blocked from full travel; Safety Disengaged - The Red Dot
showing and the trigger has full travel...MAKE SURE YOU UNDERSTAND
HOW THE SAFETY WORKS BEFORE YOU LOAD OR USE THE Combination
Rifle / Shotgun)
Top Lever: Located on top of the receiver, push to right to break open barrel
from receiver of Combination Rifle / Shotgun.
Trigger: Located in the trigger guard. If the safety is disengaged and hammer
mechanism has been cocked  and trigger is pulled to the rear the Combination
Rifle / Shotgun will discharge, if there is a live cartridge in the chamber. The
front trigger is for the Shotgun barrel (Bottom Barrel). The back trigger is for the
rifle barrel ( Top Barrel). In the case of a single selectable trigger,  one trigger is
used to fire each barrel. Barrel sequence for firing is done by the barrel selector,
see barrel selector section.
Barrel Selector: The trigger of a single trigger(selectable) Combination Rifle /
Shotgun is the barrel selector. If you push the trigger forward until you feel a
click the barrel selection will be top barrel first then bottom barrel. Once you
have moved the top leaver the selection goes back to bottom barrel then top
barrel. Thus, the gun is set to fire the bottom barrel first and then the top barrel,
as configured by the factory, and is only override able by the selector and
movement of the top leaver puts the gun back to the factory configuration.
Forend: Located below barrels in front of receiver, locks barrel assembly into
receiver, has a latch in the mid lower section that is used to lock and unlock
forend.
Rear Sight: Windage adjustable
Scope Mount Rail: 
						

							10 Directions For Assembly Of
Combination Rifle/Shotgun:
• 1) Fig 1: When you open the box of your new
IZH94 “Sever” Combination Rifle / Shotgun the
barrel and forend is separated from the main
portion of the Combination Rifle / Shotgun. To
attach the barrel and forend first remove the
plastic bags or wrapping covering the parts.
Then remove the forend from the barrel by
pulling out the lever in the lower mid section of
the forend and tipping the forend out and
away from the barrel while pulling the lever
out. Never force the forend off the barrel.
Check to make sure that the barrel is free of
foreign matter by looking down the barrel (no
blockage what-so-ever)
• 2) Fig 2: Now push the top lever to the right
and hold. Do not force the top lever.
• 3) Fig 3: Engage the lower locking lug
located on the lower portion of the barrel with
the receiver. The half round cut out on the
lower locking lug fits around the round bar in
the forward lower portion of the slot in  the
receiver. With the barrel engaged into the
receiver you should be able to swing the
barrel up into the locked position and the top
lever should move back to the center once the
barrel is locked into position. Note: The top
latch may not move completely to the center
on a new Combination Rifle / Shotgun until the
gun is broken in. The latch must move at least
three quarters of the full travel distance.
• 4) Fig 4: With the barrel locked into the
receiver pull the forearm latch out and place
the forend on receiver. With an upward swing
motion lock the forend onto the barrel. Do not
force the forend into it’s locked position on the
barrel. It may also be required to slide the
forend onto the barrel and then insert it into
the receiver and lock it with an up swing.
Sometimes it is necessary to push the latch
into it’s final flat position, never force the latch
into position.
• 5) Warning... Never fire the gun unless the