Nokia 5800 Xpress Music Manual

 
5800 XpressMusic RM-356 / RM-428Service Manual Level 1&2
     
 
                ISS U E 1  
Confidential 
1 
SERVICE MANUAL 
Level 1&2 
 
RM-356 RM-428 
 
 
 
Transceiver characteristics 
 
Band : 
RM-356: HSDPA, WCDMA 900/2100 GSM/EDGE 
850/900/1800/1900 
RM-428: HSDPA, WCDMA 850/1900 
GSM/EDGE 850/900/1800/1900 
 
Display:  
3.2’’ nHD (640x360 pixels), active area 39.6 mm x 70.4 
mm, 16:9 aspect ratio, up to 16 million colours   
 
Camera: 
3.2 Mpix with 4x digital zoom 
 
Operating System : 
S60...

 
5800 XpressMusic RM-356 / RM-428Service Manual Level 1&2
     
 
                ISS U E 1  
Confidential 
2 
 
 
 
1.
 Change history ........................................................................\
....................................................... .3 
2. Copyright........................................................................\
................................................................ 4 
3. Warnings and cautions...

 
5800 XpressMusic RM-356 / RM-428Service Manual Level 1&2
     
 
                ISS U E 1  
Confidential 
3 
1.
 CHANGE HISTORY 
Status Version  No. Date  Comments 
Draft 0.3  03.10.2008 Draft 
Approved 1.0  03.10.2008  First approved version 
 
The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to 
carry out service to NOKIA products. This Service  Manual is to be used only by authorized NOKIA 
service suppliers, and the content of it is confid ential. Please...

 
5800 XpressMusic RM-356 / RM-428Service Manual Level 1&2
     
 
                ISS U E 1  
Confidential 
4 
2.
 COPYRIGHT 
Copyright © 2008 Nokia. All rights reserved. 
Reproduction, transfer, distribution or storage of part or all of the contents in this document in 
any form without the prior written permission of Nokia is prohibited. 
Nokia, Nokia Connecting People, and Nokia X and  Y are trademarks or registered trademarks of 
Nokia Corporation. Other product and company names mentioned herein...

 
5800 XpressMusic RM-356 / RM-428Service Manual Level 1&2
     
 
                ISS U E 1  
Confidential 
5 
3.
 WARNINGS AND CAUTIONS 
Please refer to the phone’s user guide for instructions relating to operation, care and 
maintenance including important safety information. Note also the following: 
3.1  Warnings 
1.  CARE MUST BE TAKEN ON INSTALLATION IN  VEHICLES FITTED WITH ELECTRONIC ENGINE 
MANAGEMENT SYSTEMS AND ANTI–SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT 
CONDITIONS, EMITTED RF ENERGY CAN...

 
5800 XpressMusic RM-356 / RM-428Service Manual Level 1&2
     
 
                ISS U E 1  
Confidential 
6 
 
 
 
4.  ESD PROTECTION 
 
 
  Nokia requires that service points have sufficient ESD protection (against 
static electricity) when servicing the phone. 
 
 
Any product of which the covers are removed must be handled with ESD 
protection. The SIM card can be replaced without ESD protection if the 
product is otherwise ready for use. 
 
 
  To replace the covers ESD protection must be applied....

 
5800 XpressMusic RM-356 / RM-428Service Manual Level 1&2
     
 
                ISS U E 1  
Confidential 
7 
5.
 CARE AND MAINTENANCE 
This product is of superior design and crafts manship and should be treated with care. The 
suggestions below will help you to fulfil any warranty obligations and to enjoy this product for 
many years. 
•  Keep the phone and all its parts and accessories out of the reach of small children. 
•   Keep the phone dry. Precipitation, humidity  and all types of liquids or...

 
5800 XpressMusic RM-356 / RM-428Service Manual Level 1&2
     
 
                ISS U E 1  
Confidential 
8 
6.
 BATTERY INFORMATION 
Note: A new battery’s full performance is achiev ed only after two or three complete charge 
and discharge cycles! The battery can be charged and discharged hundreds of times but it will 
eventually wear out. 
When the operating time (talk-time and standby  time) is noticeably shorter than normal, it is 
time to buy a new battery. Use only batteries approved by the...

 
5800 XpressMusic RM-356 / RM-428Service Manual Level 1&2
     
 
                ISS U E 1  
Confidential 
9 
7.
 EXPLODED VIEW 
See corresponding ITEM/CIRCU IT REF in the Spare Parts Service Bulletins on NOL.  

 
5800 XpressMusic RM-356 / RM-428Service Manual Level 1&2
     
 
                ISS U E 1  
Confidential 
10 
 
8.  SERVICE DEVICES 
 
FLS-5 Flash device  
BL-5J Battery 
 
 
 
RJ-230 Universal soldering jig 
 
AC-8  Travel charger  
(AC-8C China)  
CA-101 Service cable 
 
 
 
SS-195 display removal tool 
 
 
SS-102 Camera removal tool   
 
 
NMP Standard Toolkit (v2) 
For more information, refer to the 
Service Bulletin (SB-011) on NOKIA  Online. Supplier or manufacturer contacts for tool re-order...