Philips Fm2 Service Manual

Main PCB Disassembly Procedures
Chapter 6 - Disassembly/Reassembly Guide
59
Main PCB Disassembly Procedures 
This section describes the items that may be removed/replaced from the main 
PCB assembly of the monitor. The main PCB assembly is separable from the 
front case assembly. 
Step 1. First separate the front and rear assemblies as described in the section 
“Separation of Front and Rear Case Assemblies” on page 45.
Step 2. Then remove the main PCB assembly from the front case assembly, as 
described...

Main PCB Disassembly Procedures
60Chapter 6 - Disassembly/Reassembly Guide
Step 3. Use a Phillips-head screwdriver to remove the six screws that secure the 
side panel to the socket surrounds. Access to the screws is gained 
through the holes in the side connector PCB.
Step 4. Remove the side panel from the side connector PCB.
J3
on
main
PCB
  

Main PCB Disassembly Procedures
Chapter 6 - Disassembly/Reassembly Guide
61
Replacing the Side Panel/Side Connector PCB  
Step 1. Place the side panel on the side connector PCB so that the sockets on 
the side connector PCB fit the holes in the side panel.
Step 2. Using a Phillips-head screwdriver, fasten the side connector PCB to 
the side panel using the six screws.
Step 3. Align the studs on the bottom of the side panel with the holes on the 
main PCB. Also align the pins at J3 on the main PCB with...

Main PCB Disassembly Procedures
62Chapter 6 - Disassembly/Reassembly Guide 

Chapter 7 - Spare Parts63
7
Spare Parts
Introduction
Spare parts, along with part numbers, are listed in the tables that follow. “Item 
No.” corresponds to the callout number in Figure 7 through Figure 11. The 
“Pa ge Ref.” indicates the page number of the relevant disassembly procedures in 
Chapter 6.
Small Parts Kit
Most small parts and hardware (screws, and so forth) can be found in the Small 
Parts Kit, Part Number M2922-64003. The Small Parts Kit is supplied with 
every major spare part. 

Exchange Parts
64Chapter 7 - Spare Parts
Exchange Parts
Monitor (M2922A)
Recorder (M2925A)
Table 6 Exchange Assemblies - M2922A
Exchange Part No.Description
M2922-68000 Entire monitor
M1355-69011 TOCO Transducer
M1356-69011 US Transducer
Table 7 Exchange Assemblies - M2925A
Exchange Part 
No.Description
M2925-68110 Recorder 100V, 120V
M2925-68220 Recorder 220V, 240V 

Non-Exchange Parts
Chapter 7 - Spare Parts
65
Non-Exchange Parts
Table 8 Non-Exchange Assemblies - M2922A
Item 
No.Part No.DescriptionPage 
Ref.
1 M2922-66505 Connector board 59, 61
2 M2922-66510 Interface board 56
3 M2922-40003 Battery 43, 44
4 M3921-60406 Navigation wheel 47
- M2922-64001 Housing kit -
5A & 5B M2922-64004 Display assembly kit 50, 51
6 M2922-64002 Speaker kit 41, 42
7 M2922-44301 Key pad 54
- M2922-64003 Small parts kit -
8 M2922-60511 Rear connector board 55, 57
- M3921-61000 Power...

Supplies and Accessories
66Chapter 7 - Spare Parts
Supplies and Accessories
Breakdown of Spare Parts Kits by Component
M2922-64003 - Small Parts Kit
Table 9 Supplies and Accessories - M2922A
Part No.Description
M1356-43203 Transducer knob adapters (3-pack)
Table 10 M2922-64003 Small Parts Kit
Component DescriptionQuantity
Screw, mach Phillips-head 4-40 X 3/16 4
Screw, tri-lob, Phillips-head 6 X 1/2 6
Ring retaining ext, 1/8 shaft 2
Screw, tri-lob, Phillips-head 4 X 3/8 17
Retaining ring for wheel 1
Screw...

Breakdown of Spare Parts Kits by Component
Chapter 7 - Spare Parts
67
M2922-64001 - Housing Kit 
Table 11 M2922-64001 Housing Kit
Component DescriptionQuantity
Small Parts Kit1
1. For contents of the Small Parts Kit, refer to Table 10 on page 66.
1
Front case 1
Louver cover plate 1
Handle 1
Rubber feet (cushions) 2
Speaker retainer spring 1 

Breakdown of Spare Parts Kits by Component
68Chapter 7 - Spare Parts
M2922-64002 - Speaker Kit
M2922-40003 - Battery Kit
Table 12 M2922-64002 Monitor Speaker Kit
Component DescriptionQuantity
Small Parts Kit1
1. For contents of the Small Parts Kit, refer to Table 10 on page 66.
1
Speaker housing 1
Bracket R/A 4-40 1
Speaker retainer 1
Speaker 1
Cable - speaker assembly 1
Gasket - speaker 1
Pad - battery, front/rear 1
Label - rear 1
Pad - battery, front/rear 1
Pad - battery, right 1
Pad - battery, left 1...