Troy-Bilt 7 Speed Pony Manual

1
secti On 7 — service1
secti On 7 — service
Tires
WARNING! Never exceed the maximum inflation 
pressure shown on the sidewall of the tire.
The recommended operating tire pressure is:
Approximately 10 psi for the rear tires 
Approximately 14 psi for the front tires
IMPORTANT: Refer to the tire sidewall for exact tire 
manufacturer’s recommended or maximum psi. Do not 
overinflate. Uneven tire pressure could cause the cutting deck to 
mow unevenly.
Battery
CALIFORNIA P ROPOSITION 65 WARNING!...

sectiOn 7— service
 sectiOn 7— service

To properly sharpen the cutting blades, remove equal amounts 
of metal from both ends of the blades along the cutting edges, 
parallel to the trailing edge, at a 25° to 30° angle.
IMPORTANT: If the cutting edge of the blade has already been 
sharpened to within 1 5⁄8” from the edge, or if any metal separation 
is present, replace the blades with new ones. See Fig. 7-5.
CAUTION : If the cutting edge of the blade has previously been 
sharpened,...

3
secti On 7 — service
3
secti On 7 — service

Remove the deck belt from around all pulleys, including 
the deck idler pulley.
Route the new belt as shown in Fig. 7-7.
Remount the belt guards removed earlier.
5.
6.
7.
Figure -
Deck Idler Pulleys
Engine Pulley
Idler Bracket
42-Inch Deck
Changing the Transmission Drive Belt
NOTE: Several components must be removed and special tools 
(i.e. air/impact wrench) in order to change the tractor’s drive belt. 
See an authorized Troybilt...

ProblemCauseRemedy
Engine fails to start PTO/Blade engaged. 
Spark plug wire disconnected.
Fuel tank empty, or stale fuel.  
Choke not activated.
Faulty spark plug.
Blocked fuel line.
Engine flooded.
Parking brake not engaged
 Throttle control lever not in correct starting 
position. 
1.
2.
3.
4.
5.
6.
7.
8.
9.
Place blade engage lever in disengaged 
(OFF) position. 
Connect wire to spark plug. 
Fill tank with clean, fresh (less than 30 days 
old) gas. 
Place the throttle control in CHOKE position....

NOTE: Troybilt LLC reserves the right to change product specifications, designs and equipment without notice and without incurring 
obligation.
NOTE: Download a complete Parts Manual free of charge at www.troybilt.com or phone (800) 828-5500 to purchase a  Parts Manual. 
Be sure to have your model number and serial number ready. These can be found on the model plate located under the seat. Refer to 
page 2 for more information regarding locating your model and serial numbers.
ComponentPart Number and...

The following attachments and accessories are compatible for the Troy-bilt Pony Lawn Tractor. See the retailer from which you purchased 
your tractor, an authorized Troy-bilt Service Dealer or phone (800) 828-5500 for information regarding price and availability.
CAUTION: This Troy-Bilt Lawn Tractor is NOT designed for use with any type of ground-engaging attachments (e.g. tiller or 
plow). Use of this type of equipment WILL void the tractor’s warranty.
Model NumberDescription
OEM-190-679Bumper...

CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT 
YOUR WARRANTY RIGHTS AND OBLIGATIONS
The California Air Resources Board and MTD Consumer Group Inc are pleased to explain the evaporative emission control system warranty on 
your 2007 lawn mower. In California, new lawn mower must be designed, built and equipped to meet the State’s stringent anti-smog standards. 
MTD Consumer Group Inc must warrant the EECS on your lawn mower for the period of time listed below provided there has been no abuse, 
neglect...

MANUFACTURER’S LIMITED WARRANTY FOR
GDOC-100020 REV. A
The limited warranty set for th below is given by Troy-Bilt LLC with 
respect to new merchandise purchased and used in the United States 
and /or its territories and possessions, and by MTD Products Limited 
with respect to new merchandise purchased and used in Canada 
and /or its territories and possessions (either entity respectively, 
“Troy-Bilt”).
“Troy-Bilt” warrants this product (excluding its Normal Wear Parts 
and Attachments as described...

MTD LLC, P.O. BOX 361131 CLEVELAND, OHIO 44136-0019
Impreso en Estados Unidos de América
Manual del OperadOr
Medidas importantes de seguridad • Configuración • Funcionamiento •  Mantenimiento • Servicio • Solución de problemas •  Garantía
ADVERTENCIA
LEA Y SIGA TODAS LAS INSTRUCCIONES DE ESTE MANUAL  
ANTES DE PONER EN FUNCIONAMIENTO ESTA MÁQUINA.   
SI NO RESPETA ESTAS INSTRUCCIONES PUEDE PROVOCAR LESIONES PERSONALES.
Tractor de Césped — Pony 

Asistencia al Cliente
En caso de tener problemas para montar este producto o de tener dudas con respecto a los controles, funcionamiento 
o mantenimiento de esta máquina, puede solicitar la ayuda de expertos. Elija entre las opciones que se presentan a 
continuación:
Visite nuestro sitio web en www.troybilt.com
Llame al representante de Atención al Cliente al (800) 828-5500 o (330) 558-7220
Escríbanos a Troy-Bilt LLC • P.O. Box 361131 • Cleveland, OH • 44136-0019
◊
◊
◊
Gracias por comprar un tractor...