Honda Eu 2000 I Owners Manual

49
Use a brush to remove carbon deposits from the spark arrester
screen.
Inspect the screen for breaks or tears and replace it if necessary.
Check the muffler gasket; replace if damaged. Reinstall the muffler
gasket, the spark arrester, the muffler, and the muffler protector in
the reverse order of removal. 3.
4.
5.
06/12/21 09:21:15 31Z07602_050 

50 TRANSPORTING/STORAGE
TRANSPORTING
Take care not to drop or strike the generator when transporting. Do not
place heavy objects on the generator. To prevent fuel spillage when transporting, the generator should be
secured upright in its normal operating position, with the engine
switch OFF and the fuel tank cap vent lever turned fully
counterclockwise to the ‘‘OFF’’position. If the generator has been used, allow it cool for at least 15 minutes
before loading the generator on the transport vehicle. A hot...

Î
Î
Î
51
STORAGE
STORAGE TIME RECOMMENDED SERVICE PROCEDURE TO
PREVENT HARD STARTING Before storing the unit for an extended period:
1. Be sure the storage area is free of excessive humidity and dust.
2. Service according to the table below:
Less than 1 month
1 to 2 months
2 to 6 months
6 months or moreNo preparation required
Fill with fresh gasoline and add gasoline
stabilizer . Run the engine for 10 minutes to
use up the non-treated gasoline.
Fill with fresh gasoline and add gasoline
stabilizer ....

52
Storage Procedure
You can be burned or seriously injured when handling fuel. Gasoline is highly flammable and explosive.
Keep heat, sparks, and flame away.
Handle fuel only outdoors.
Wipe up spills immediately.
DRAIN SCREW
NON-CALIFORNIA TYPE SHOWN
Drain the gasoline.
Unscrew the fuel tank cap, remove the debris screen, and empty
the fuel tank into an approved gasoline container using a
commercially available hand siphon. Reinstall the debris screen
and the fuel tank cap.
Loosen the cover screw and...

53
Change the engine oil (see page 42).
Remove the spark plug, and pour about a tablespoon of clean
engine oil into the cylinder. Crank the engine several revolutions to
distribute the oil, then reinstall the spark plug.
Reinstall the spark plug cap on the spark plug securely.
Reinstall the spark plug maintenance cover.
Reinstall the maintenance cover and tighten the cover screw
securely.
Pull the starter grip slowly until you feel resistance, then return the
starter grip gently. This closes the valves...

54 TROUBLESHOOTING
When the engine will not start:
Is there fuel in the
tank?
Is there enough oil
in the engine?
Is the spark plug in
good condition?
If the engine still
does not start, take
the generator to an
authorized Honda
generator dealer.Refill the fuel tank
(see page 30).
Add the recom-
mended oil (see
page 28).
Clean, readjust gap,
and dry the spark
plug. Replace it if
necessary (see
page 46). YES
YESNO
NO
YESNO
06/12/21 09:21:43 31Z07602_055 

55
Appliance does not operate:
Check the electrical ap-
pliance or equipment for
any defects.
Is the DC circuit protector
on? No electricity at the DC receptacle:Take the generator to an
authorized Honda generator
dealer.
Take the generator to an
authorized Honda generator
dealer.
Replace the electrical ap-
pliance or equipment.
Take the electrical ap-
pliance or equipment to an
electrical shop for repair.
Stop and restart the engine. Is the output indicator
light ON? (see page 13)
Is the overload...

56 WIRING DIAGRAM
06/12/21 09:22:11 31Z07602_057 

57 INITIAL USE INSTRUCTIONS
ADDING ENGINE OIL
WITHOUT OIL
Do not overfill the engine with oil.
COVER SCREW
MAINTENANCE COVER
OIL FILLER CAP/DIPSTICK
UPPER LIMIT
The generator is shipped in the engine.
With the generator in a level position, remove the oil filler cap/
dipstick.
If the engine is overfilled, the
excess oil may be transferred to the air cleaner housing and air filter.
Screw in the oil filler cap/dipstick securely.
Reinstall the maintenance cover. Add enough SAE 10W-30 API service...

58
ADDING FUEL
Gasoline is highly flammable and explosive.
Stop the engine and keep heat, sparks, and flame away.
Handle fuel only outdoors.
Wipe up spills immediately. You can be burned or seriously injured when handling fuel. This engine is certified to operate on unleaded gasoline with a pump
octane rating of 86 or higher.
Never use stale or contaminated gasoline or an oil/gasoline mixture.
Avoid getting dirt or water in the fuel tank.
If the fuel level is low, refuel in a well-ventilated area with...