GE Vivid 7 Service Manual

GE HEALTHCARE
DIRECTION FC091194, REVISION 11    VIVID 7 SERVICE MANUAL 
Chapter 1 - Introduction 1 - 13
“CAUTION - Dangerous voltage” (the 
lightning flash with arrowhead in 
equilateral triangle) is used to indicate 
electric shock hazards.
Various
“Mains OFF” Indicates the power off 
position of the mains power switch.Rear of system adjacent to mains switch
“OFF/Standby” Indicates the power off/
standby position of the power switch.
CAUTION
This Power Switch DOES NOT 
ISOLATE Mains Supply Adjacent to...

GE HEALTHCARE
DIRECTION FC091194, REVISION 11    VIVID 7 SERVICE MANUAL 
1 - 14 Section 1-3 - Important Conventions
The following product pollution 
control information is provided 
according to SJ/T11364-2006 
Marking for Control of Pollution 
caused by Electronic Information 
Products.
This symbol indicates the product 
contains hazardous materials in excess 
of the limits established by the Chinese 
standard SJ/T11363-2006 
Requirements for Concentration Limits 
for Certain Hazardous Substances in...

GE HEALTHCARE
DIRECTION FC091194, REVISION 11    VIVID 7 SERVICE MANUAL 
Chapter 1 - Introduction 1 - 15
Section 1-4
Safety Considerations
1-4-1 Overview
1-4-2 Introduction
The following safety precautions must be observed du ring all phases of operation, service and repair of 
this equipment. Failure to  comply with these precauti ons or with specific warnings elsewhere in this 
manual, violates safety standards of design,  manufacture and intended use of the equipment.
Table 1-7    Contents in...

GE HEALTHCARE
DIRECTION FC091194, REVISION 11    VIVID 7 SERVICE MANUAL 
1 - 16 Section 1-4 - Safety Considerations
1-4-3 Human Safety
  
Operating personnel must not remove the system covers. 
Servicing should be performed by authorized personnel only. 
Only personnel who have participat ed in a Vivid 7 Training are authorized to service the equipment.
DANGERDANGEROUS VOLTAGES, CAPABLE OF  CAUSING DEATH, ARE PRESENT IN 
THIS EQUIPMENT. USE EXTREME CAUT ION WHEN HANDLING, TESTING AND 
ADJUSTING....

GE HEALTHCARE
DIRECTION FC091194, REVISION 11    VIVID 7 SERVICE MANUAL 
Chapter 1 - Introduction 1 - 17
1-4-4 Mechanical Safety
    
WARNINGWARNINGPRIOR TO ELEVATING SCANNER, VERIFY THAT THE KEYBOARD IS LOCKED IN ITS 
LOWEST POSITION. VERIFY THAT THE FRONT BRAKE IS LOCKED AND THE 
SCANNER IS UNABLE TO SWIWEL. VERIFY THAT THE REAR BRAKES ARE IN THE 
LOCKED POSITION.
WARNINGWARNINGWHEN THE UNIT IS RAISED FOR A REPAIR OR MOVED ALONG ANY INCLINE, USE 
EXTREME CAUTION SINCE IT MAY BECOME UNSTABLE AND TIP...

GE HEALTHCARE
DIRECTION FC091194, REVISION 11    VIVID 7 SERVICE MANUAL 
1 - 18 Section 1-4 - Safety Considerations
1-4-4 Mechanical Safety (cont’d)
 
NOTE: Special care should be taken w hen transporting the unit in a vehicle:
• Lock Operator Panel (Control Console) in place.
• Eject any Magneto Optical disk, CD or DVD from their drive.
• Secure the unit in an upright position.
• Lock the casters (wheels) (brake)
• DO NOT use the Operator Panel (Cont rol Console) as an anchor point.
• Place the probes...

GE HEALTHCARE
DIRECTION FC091194, REVISION 11    VIVID 7 SERVICE MANUAL 
Chapter 1 - Introduction 1 - 19
1-4-5 Electrical Safety
1-4-5-1 Safe Practices Follow these guidelines to minimize shock hazards whenever you are using the scanner;
• The equipment chassis must be con nected to an electrical ground. 
• The unit is equipped with a three-conductor AC power  cable. This must be plugged into an approved 
electrical outlet with safety ground.
• The power outlet used for this equipment shou ld not be...

GE HEALTHCARE
DIRECTION FC091194, REVISION 11    VIVID 7 SERVICE MANUAL 
1 - 20 Section 1-5 - Labels Locations
Section 1-5
Labels Locations
1-5-1 Labels on Front of M onitor and Operator Panel
 
Table 1-8    Labels on Front of Monitor and Operator Panel 
DESCRIPTIONILLUSTRATION
Label, Vivid 7 (Monitor)
(Introduced in 2001)
Label, Vivid 7 (Monitor)  (Introduced in 2002)
Label, Vivid 7 PRO (Monitor)  (Introduced in 2002)
Label, Vivid 7 Dimension (Monitor) (Introduced 2004) 
For Vivid 7 Dimension with LCD...

GE HEALTHCARE
DIRECTION FC091194, REVISION 11    VIVID 7 SERVICE MANUAL 
Chapter 1 - Introduction 1 - 21
Label, GE Logo
 
Label, On/Off Switch
(Two versions of the label have been used, the one to the  right is the latest version.)
Table 1-8    Labels on Front of Monitor and Operator Panel (cont’d)
DESCRIPTIONILLUSTRATION
ON/OFF:     FC314104 03
press onceOR
LABEL POSITION 

GE HEALTHCARE
DIRECTION FC091194, REVISION 11    VIVID 7 SERVICE MANUAL 
1 - 22 Section 1-5 - Labels Locations
1-5-2 Labels on Rear of LCD Monitor
 
Table 1-9    Label on Rear of LCD Monitor
DESCRIPTIONILLUSTRATION
Firmware label LCD monitor 
FOR USA ONLY:  LCD MONITOR MERCURY HG.
Introduced October 1, 2007