Honda Eu 2000 I Owners Manual

							59
FUEL TANK CAP
UPPER LIMIT MARKFUEL TANK CAP
UPPER LIMIT MARK NON-CALIFORNIA TYPE CALIFORNIA TYPE
NON-CALIFORNIA TYPE CALIFORNIA TYPE
TETHER
Remove the fuel tank cap.
Fuel can damage paint and plastic. Be careful not to spill fuel when
filling your fuel tank. Damage caused by spilled fuel is not covered
under warranty.
Fuel carefully to avoid spilling fuel.
Do not fill the fuel tank above the upper limit mark on the fuel
strainer. 1.
2.
06/12/21 09:22:40 31Z07602_060 
						

							µ
µ
µ
µ
µ
60
BEFORE OPERATION
GENERATOR SAFETY
CONTROLS
GENERATOR USE
PRE-OPERATION CHECK
STARTING THE ENGINE
STOPPING THE ENGINE
MAINTENANCE SCHEDULE
VENT LEVER
OOFFFFOONN
VENT LEVEROONNOOFFFF NON-CALIFORNIA TYPE CALIFORNIA TYPE
After refueling, tighten the fuel cap securely (Non-California type).
After refueling, tighten the fuel cap until it clicks (California type).
Keep the vent OFF for storage or transport, and ON to run the
generator.
Before using the generator, all generator operators must read the
following chapters and sections:
(pages )
(pages )
(pages )
(pages )
(pages )
(page )
(page ) Move the generator at least 10 feet (3 meters) away from the fueling
source and site before starting the engine.
After initial fueling (or anytime the generator is run completely out of
fuel), starting the engine may require additional pulls of the starter
grip. This generator utilizes a vacuum operated fuel pump and may
require additional pulls to draw fuel into the carburetor.
58
11 16
17 27
28 32
33 34
35
41 3.
06/12/21 09:22:49 31Z07602_061 
						

							µ
¶
¶ µ
µ ¤· ¥¤· · ¥
61 SPECIFICATIONS
Tuneup
ITEM SPECIFICATION Dimensions
Engine
Generator
MAINTENANCE EAAJ
8.5: 1
Forced air
Full transistor
CR5HSB (NGK) GX100 20.2 in (512 mm)
11.4 in (290 mm)
16.7 in (425 mm)
45.9 lbs (20.8 kg)
6.01 cu-in (98.5 cm
)
0.42 US qt (0.40
)
0.95 US gal (3.6
)
Spark plug gap
Valve clearance (cold)
Other specifications No other adjustments needed.IN: 0.15 0.04 mm
EX: 0.20 0.04 mm 0.024 0.028 i n
(0.60 0.70 mm)2,000 VA 1,600 VA
13.3 A
60 Hz
120 V Model
Description code
Length
Width
Height
Dry weight
Model
Engine type
Displacement
Bore Stroke
Compression ratio
Engine speed
Cooling system
Ignition system
Oil capacity
Fuel tank capacity
Spark plug
Model
Type
Rated voltage
Rated frequency
AC output Rated current
Rated output
Maximum output
DC output
Refer to page 46
See your authorized
Honda dealer. EU2000i
EU2000i2.20 1.57 in (56.0 40.0 mm)
California type (AC type)
Non-California type (AN type)
4-stroke, overhead camshaft, single cylinder
4,300 5,000 rpm (with Eco-Throttle switch OFF)
Only for charging 12V automotive batteries.
Maximum charging output= 8A
Specifications are subject to change without notice.
06/12/21 09:23:04 31Z07602_062 
						

							62 TECHNICAL & CONSUMER INFORMATION
Dealer Locator Information
Customer Service Information Visit our website:
www.hondapowerequipment.com
Servicing dealership personnel are trained professionals. They should
be able to answer most questions you may have. If you encounter a
problem that your dealer does not solve to your satisfaction, please
discuss it with the dealership’s management. The Service Manager or
General Manager can help. Almost all problems are solved in this way.
If you are dissatisfied with the decision made by the dealership’s
management, contact the Honda Power Equipment Customer
Relations Office. You can write to:American Honda Motor Co., Inc.
Power Equipment Division
Customer Relations Office
4900 Marconi Drive
Alpharetta, Georgia 30005-8847
Or  telephone:  (770) 497-6400  8:30 am to 7:00  pm ET
When you write or call, please give us this information: Model and serial number (see page )
Name of dealer who sold the generator to you
Name and address of dealer who services your generator
Date of purchase
Your name, address, and telephone number
A detailed description of the problem
To find an authorized Honda Servicing Dealer anywhere in the United
States:
10
06/12/21 09:23:14 31Z07602_063 
						

							63
Honda Publications
Shop Manual
Parts Catalog
Accessories Catalog This manual covers complete maintenance and overhaul procedures.
It is intended to be used by a skilled technician.
Available through your Honda dealer or through Helm Inc. at 1 888-
292-5395 or visit  www.hondapowerequipment.com
This manual provides complete, illustrated parts lists. Available
through your Honda dealer.
Your authorized Honda power equipment dealer offers a wide
selection of accessories (optional equipment) to make your generator
even more useful.
Visit  www.hondapowerequipment.com  and click  on
Generators and Welders to see the entire catalog of accessories.
Especially popular accessories include: Covers
Spill-proof gasoline cans
Battery charging cords
Parallel connection cables
Transfer switches and kits
Plugs and connectors
06/12/21 09:23:23 31Z07602_064 
						

							64
Distributor’s Limited Warranty
PRODUCTS COVERED BY
THIS WARRANTYLENGTH OF WARRANTY
(from date of original retail purchase)
To Qualify for this Warranty:
What American Honda will Repair or Replace Under Warranty:
To Obtain Warranty Service:
The product must be purchased in the United States, Puerto Rico, or
the U.S. Virgin Islands from American Honda or a dealer authorized by
American Honda to sell those products. This warranty applies to the
first retail purchaser and each subsequent owner during the applicable
warranty time period.
American Honda will repair or replace, at its option, any part that is
proven to be defective in material or workmanship under normal
use during the applicable warranty time period. Warranty repairs
and replacements will be made without charge for parts or labor.
Anything replaced under warranty becomes the property of
American Honda Motor Company, Inc. All parts replaced under
warranty will be considered as part of the original product and any
warranty on those parts will expire coincident with the original
product warranty.
You must take the Honda generator and proof of original retail
purchase date, at your expense, to any Honda Power Equipment
dealer in the United States, Puerto Rico, or the U.S. Virgin Islands
who is authorized to service that product, during the dealer’s normal
business hours. If you are unable to obtain warranty service, or are
dissatisfied with the warranty service you receive, take the following
steps: First, contact the owner of the dealership involved; normally
this should resolve the problem. However, if you should require
further assistance, write or call the Power Equipment Customer
Relations Department of American Honda Motor Co., Inc. Refer to
page for contact information.Noncommercial/
Nonrental
24 months
24 months
See your authorized Honda servicing
dealer for details EU series generators
Engine
Generator Electrical and
Frame Components
Parts & Accessories.Commercial/
Rental
24 months
12 months
62
06/12/21 09:23:32 31Z07602_065 
						

							65
Exclusions:
Disclaimer of Consequential Damage and Limitation of Implied Warranties:
Your Warranty Rights And Obligations:
California
Emission Control System Warranty This warranty does not extend to parts affected or damaged by
accident and/or collision, normal wear, fuel contamination, use in an
application for which the product was not designed, or any other
misuse, neglect, incorporation or use of unsuitable attachments or
parts, unauthorized alteration, or any causes other than defects in
material or workmanship of the product.
American Honda disclaims any responsibility for loss of time or use of
the product, transportation, commercial loss, or any other incidental or
consequential damage. Any implied warranties are limited to the
duration of this written limited warranty. Some states do not allow
limitations on how long an implied warranty lasts and/or do not allow
the exclusion or limitation of incidental or consequential damages, so
the above exclusions and limitations may not apply to you. This
warranty gives you specific legal rights, and you may also have other
rights which vary from state to state.
Your new Honda Power Equipment engine complies with the U.S. EPA,
Environment Canada and State of California emission regulations.
American Honda Motor Co., Inc. provides the emission warranty
coverage for engines in the United States, and its territories. Honda
Canada Inc. provides the emission warranty for engines in the
13 provinces and territories of Canada. In the remainder of this
Emission Control System Warranty, American Honda Motor Company
Inc. and Honda Canada Inc. will be referred to as Honda.
The California Air Resources Board and Honda are pleased to explain
the emission control system warranty on your Honda Power
Equipment engine. In California, new spark-ignited small off-road
equipment engines must be designed, built and equipped to meet the
State’s stringent anti-smog standards.
06/12/21 09:23:38 31Z07602_066 
						

							66
Other States, U.S. territories and Canada
All of the United States and Canada
Manufacturer’s Warranty Coverage:
Owner’s Warranty Responsibility:
In other areas of the United States and in Canada, your engine must be
designed, built, and equipped to meet the U.S. EPA and Environment
Canada emission standards for spark-ignited engines at or below
19 kilowatts.
Honda must warrant the emission control system on your power
equipment engine for the period of time listed below, provided there
has been no abuse, neglect or improper maintenance of your power
equipment engine. Where a warrantable condition exists, Honda will
repair your power equipment engine at no cost to you including
diagnosis, parts and labor.
Your emission control system may include such parts as the
carburetor or fuel injection system, the ignition system, and catalytic
converter. Also included may be hoses, connectors and other
emission-related assemblies.
The 1995 and later power equipment engines are warranted for two
years. If any emission related part on your engine is defective, the part
will be repaired or replaced by Honda.
As the power equipment engine owner, you are responsible for the
performance of the required maintenance listed in your owner’s
manual. Honda recommends that you retain all receipts covering
maintenance on your power equipment engine, but Honda cannot
deny warranty coverage solely for the lack of receipts or for your
failure to ensure the performance of all scheduled maintenance.
As the power equipment engine owner, you should however be aware
Honda may deny you warranty coverage if your power equipment
engine or a part has failed due to abuse, neglect, improper
maintenance, or unapproved modifications.
You are responsible for presenting your power equipment engine to a
Honda Power Equipment dealer as soon as a problem exists. The
warranty repairs should be completed in a reasonable amount of time,
not to exceed 30 days.
06/12/21 09:23:43 31Z07602_067 
						

							67
Warranty Coverage:
If you have any questions regarding your warranty rights and
responsibilities, you should contact the Honda Office in your region:
American Honda Motor Co., Inc.
Power Equipment Customer
Relations
4900 Marconi Drive
Alpharetta, Georgia 30005-8847
Telephone: (770) 497-6400Honda Canada Inc.
Power Equipment Customer
Relations
715 Milner Avenue
Toronto, ON M1B 2K8
Telephone: (888) 946-6329
Honda power equipment engines manufactured after January 1, 1995
and sold in the State of California, U.S. EPA certified engines
manufactured on or after September 1, 1996 and sold in all of the
United States, and Canadian certified engines manufactured on or
after January 1, 2005 are covered by this warranty for a period of two
years from the date of delivery to the original retail purchaser. This
warranty is transferable to each subsequent purchaser for the duration
of the warranty period.
Warranty repairs will be made without charge for diagnosis, parts or
labor. All defective parts replaced under this warranty become the
property of Honda. Warranted parts are listed under Emission Control
System Warranty Parts on page . Normal maintenance items, such
as spark plugs and filters, that are on the warranted parts list are
warranted up to their required replacement interval only.
Honda is also liable for damages to other engine components caused
by a failure of any warranted part during the warranty period.
Only Honda approved replacement parts may be used in the
performance of any warranty repairs and must be provided without
charge to the owner. The use of replacement parts not equivalent to
the original parts may impair the effectiveness of your engine
emission control system. If such a replacement part is used in the
repair or maintenance of your engine, and an authorized Honda dealer
determines it is defective or causes a failure of a warranted part, your
claim for repair of your engine may be denied. If the part in question is
not related to the reason your engine requires repair, your claim will
not be denied.or
69
06/12/21 09:23:48 31Z07602_068 
						

							68
To Obtain Warranty Service:
Exclusions:
You must take your Honda Power Equipment engine or the product
on which it is installed, along with your sales registration card or
other proof of original purchase date, at your expense, to any Honda
Power Equipment dealer who is authorized by Honda to sell and
service that Honda product during his normal business hours.
Claims for repair or adjustment found to be caused solely by defects
in material or workmanship will not be denied because the engine
was not properly maintained and used.
If you are unable to obtain warranty service, or are dissatisfied with
the warranty service you received, contact the owner of the
dealership involved. Normally this should resolve your problem.
However, if you require further assistance, write or call the Honda
Power Equipment Customer Relations Department in your region.
Failures other than those resulting from defects in material or
workmanship are not covered by this warranty. This warranty does not
extend to emission control systems or parts which are affected or
damaged by owner abuse, neglect, improper maintenance, misuse,
misfueling, improper storage, accident and/or collision, the
incorporation of, or any use of, any add-on or modified parts,
unsuitable attachments, or the unauthorized alteration of any part.
This warranty does not cover replacement of expendable maitenance
items made in connection with required maintenance services after
the item’s first scheduled replacement as listed in the maintenance
section of the product owner’s manual, such as: spark plugs and filters.
06/12/21 09:23:51 31Z07602_069