GE S5 Service Manual

							Frame Unit for F-CM(C)1 (Rev. 04), F-CM(C)REC1 (Rev. 01)
25
                                          Document no. M1044470-01
4.2 Recorder Unit
4.2.1 Troubleshooting chart      
Problem Cause What to do
Recorder will not start.
No error messages shown.Connector board loose. Check connector board connections.
Recorder board faulty. Replace the recorder board.
Recorder unit faulty. Replace the recorder unit.
Recorder works but nothing appears 
on the paper.Active side of the paper downwards. Turn the paper roll over.
To test which side is active: Place the 
paper on a hard surface and draw a line 
with a fingernail - a dark line will appear 
on the active (thermal) side.
Recorder unit faulty. Replace the recorder unit.
Message Explanation
Recorder: out of paper Release paper jam or insert a roll of paper into the 
recorder.
Recorder: cover open Close the recorder cover correctly.
Recorder: thermal array overheat Recorder overheated. Stop using and allow it to cool 
down.
Recorder: input voltage low +15 Vrec is too low. Check the connectors and connector 
board.
Recorder: input voltage high +15 Vrec is too high. Check the connectors and connector 
board.
Recorder system error 
1, 2, 3System error. 
If the problem persists, replace the recorder unit.
Recorder: module removed A communication error due to a fault in the recorder or in 
the Central Processing Board. 
						

							Datex-Ohmeda S/5 Compact Anesthesia and Compact Critical Care Monitors
26
Document no. M1044470-01                                                                           
5 Earlier revisions
This manual covers the earlier revisions of the S/5 Compact Anesthesia Monitor or S/5 Compact 
Critical Care Monitor. 
						

							Appendix A, Service check form, S/5 Compact Anesthesia Monitor, S/5 Compact Critical Care Monitor
A-1
Document no. M1044470-01
APPENDIX A Service check form, S/5 Compact Anesthesia Monitor, 
S/5 Compact Critical Care Monitor 
OK = Test OK            N.A. = Test not applicable           Fail = Test failed Customer
 
Service Module type S/N
Service engineer
 Date
 Monitor Installation
 
F- E- E-
S- E- M-
L- M- N-
      OK          N.A.         Fail     OK          N.A.         Fail
1. Side Frame Unit
                           2. PMB and the Connector 
Boards                           
3. Frame Unit reattached
                           4. Battery slot
                           
5. External parts
                           6. Module connections
                           
7. Fan filter
                           8. Recorder
                           
9. Primary fuses
                           10. Stand-by LEDs
                           
11. Start-up
                           12. Module recognition
                           
13. Main software   L-Power Management board 
software    
14. Content of service log
                           
Notes
 
 
  
						

							Datex-Ohmeda S/5 Compact Anesthesia and Compact Critical Care Monitors
A-2
Document no. M1044470-01
15. Voltages
+15 V 14.50...15.50 V
-15V -14.50...-15.50 V
+15VD 14.50...15.50 V
+5V 4.80...5.30 V
VBUS 10.00…17.00V
+12V 11.50…12.50V
+3.3 V 3.00…3.60V
VBUS 10.00…17.00V
      OK          N.A.         Fail
16. Module communication
                                                    
17. Battery voltage 10...17 V
18. Monitor temperature 20...40 C
19. Battery operation
                           20. Mains power recognition
                           
Notes
 
 
Recorder unit
     OK          N.A.         Fail     OK          N.A.         Fail
21. Recorder messages
                           22. Recording
                           
23. Paper speed
                           24. Quality of recording
                           
Notes
 
 
 
 
 
  
						

							Appendix A, Service check form, S/5 Compact Anesthesia Monitor, S/5 Compact Critical Care Monitor
A-3
Document no. M1044470-01
General 
 
     OK          N.A.         Fail     OK          N.A.         Fail
25. Service reset switch
                           26. Battery capacity
                           
27. Battery charging
                           28. Service Log reset
                           
29. Electrical safety check
                           30. Final cleaning
                           
Notes
 
 
Used spare parts 
Signature   
						

							Datex-Ohmeda S/5 Compact Anesthesia and Compact Critical Care Monitors
A-4
Document no. M1044470-01
For your notes: 
						

							All specifications are subject to change without notice.
CAUTION: U.S. Federal law restricts this device to sale by or on the order of a licensed medical practitioner.
Outside the USA, check local laws for any restriction that may apply.
M1031521
March, 2006
Datex-Ohmeda Inc.
P.O. Box 7550
Madison, WI 53707-7550, USA
Tel: +1 608 221 1551
Fax: +1 608 222 9147
GE Healthcare Finland Oy
P.O. Box 900
FI-00031 GE, FINLAND
Tel: +358 10 39411
Fax: +358 9 1463310
www.gehealthcare.com
Copyright  2006 General Electric Company
Datex-Ohmeda
S/5
TM Compact Anesthesia Monitor
S/5
TM  Compact Critical Care Monitor
Spare Parts 
						

							Table of contents
i
                                                                                  Document no. M1031521
Table of contents
Table of contents i
1 S/5 Compact Monitor Display Unit 1
1.1 F-CM(C)REC1 rev. 00, 01, F-CM(C)1 rev.00...04. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1.1.1 Display unit, bottom unit, F-CM(C)REC1 rev. 00, 01, F-CM(C)1 rev.00...03  . . . . . . . . . . . . . 3
1.1.2 Display unit, bottom unit, F-CM(C)1 rev.04 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1.1.3 Front unit, F-CM(C)(REC)1 rev. 00  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
1.1.4 Front unit, F-CM(C)REC1 rev. 01, F-CM(C) rev.01, rev.02  . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
1.1.5 Front unit, F-CM(C) rev.03...04. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
1.1.6 Central Processing Board  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
2 S/5 Compact Monitor Frame 13
2.1 F-CM(REC)1, F-CMC(REC)1 rev. 00 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
2.2 S/5 Compact Monitor Frame, F-CM(C)1 rev. 01, rev. 02, rev. 03, F-CM(C)REC1  rev.01  . . . . . . . . . .15
2.3 Side frame unit, F-CM1, F-CMC1 rev.02, rev.03  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
2.4 S/5 Compact Monitor Frame, F-CM(C)1 rev. 04  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18
3 Software licenses 20
4Upgrade Kits 20 
						

							Datex-Ohmeda S/5 Compact Anesthesia and Compact Critical Care Monitors
ii
Document no. M1031521