Vodavi Starplus 616 Flex Electronic Key System Installation Manual

							800.6 POWEF? FAILURES 
The loss of commercial power will shut the system 
down unless external battery backup is provided. 
This loss of power could come from tripped circuit 
breakers, AC cords unplugged, or a fuse blown. 
When a power failure occurs, working toward the 
source, test for voltage. The power monitor LED will 
remain lit when power is present. Since the proces- 
sor or power failure will cause switchover to the 
power failure telephone, the LED should be used to 
determine whether it is a power failure or processor 
failure. It can be seen through the bottom air vents 
located on the front cover of the KSU. 
800.9 KEY TELEPHONE FAILURES 
The following statements should be considered 
when isolating & categorizing key telephone failures: 
Is the reported fault: 
A. Present on one telephone only? Check wiring, 
programming, telephone and KSU. Move tele- 
phone to a good working position to eliminate 
possible telephone failure. 
5. Common to station numbers in pairs (l-2, 3-4, 
5-6, etc.)? Check wiring polarity & KSU. 
C. Common to all station numbers? Check pro- 
gramming & KSU. 
D. Associated with a key telephone that was re- 
cently moved? Check ;wiring, programming, 
telephone & KSU. 
E. Associated with programming changes made 
recently? (Ringing, CO line access, etc.) 
Check for proper & accurate programming. 
F. Occurring intermittently? Set up a test to dupli- 
cate the problem. 
G. Accompanying a software failure? Test the 
feature operation, programming & KSU. 
800.10 COlPBX LINE FAILURES 
Problems with CO/PBX lines can be isolated and 
categorized by the following statements: 
Is the reported fault: 
A. Present on one CO line only? Check the af- 
fected line, wiring, plug connections & KSU. 
B. Common to 2 or more CO lines? Check the 
lines, wiring & KSU. 
C. Associated with a key telephone? Check pro- 
gramming, telephone & KSU. 
D. Associated with signaling (DTMF, dial pulse)? 
Check programming, CO line & KSU. 
E. Associated with CO incoming ringing? Check 
programming & KSU. 
F. Occurring intermittently’? Set up test to dupli- 
cate problem. Once the problem can be dupli- 
sTARPLUS@ 616 FLEX KEY TELEPHONE SYSTEM 
cated, check programming, telephone, CO line 
or KSU. 
800.11 FEATURE OPERATION FAILURES 
All operational features are controlled by software 
and specific database assignments. Most features 
are provided exclusively by software. However 
some require supporting equipment. For this rea- 
son, database assignments should be checked be- 
fore corrective maintenance is performed. Also 
check for proper usage by the customer, as feature 
failures are often the fault of the user. Features that 
use supporting equipment could have faulty equip- 
ment. This should be checked. 
The following is a list of features that use additional 
equipment: 
@ Alarm - alarm system 
0 Background Music - music source connections 
l Battery Back-up - battery package & charger 
l Loud Bell Control - external power source & 
ringing device 
l CO Line Control - ancillary equipment 
l Power Failure Transfer - telephone wiring 
l External Paging - amplifier, speaker & connec- 
tions 
800-2 
ISSUE 1, JANUARY 1991  
						

							~ARPLUS@ 616 FLEX KEY TELEPHONE SYSTEM 
APPENDIX A 
DATA BASE PROGRAMMING FORMS 
Appendix A-l Station Programming Chart 
STATION NUMBER 
DEFAULT 
VALUES 
Class of O, 
Service l-6 
:. 
..” 
Speed Dial 
Alarm 
Receive 02 
02 2 
3 
Auto Select 02 5 
Call Forward 02 6 
Headset 03 1 
FROM TO 
FROM TO Flexible Station Number Assignment 
Program Code (04) 
FROM TO FROM TO 
FROM TO 
ISSUE 1, JANUARY 1991 APPENDIX A-l 
x .i  
						

							sTARPLUS@ 616 FLEX KEY TELEPHONE SYSTEM 
Appendix A-2 Flexible Button Programming Chart (08) 
2 3 4 
6 7 6 
10 11 
12 
14 15 16 
20 21 22 
, 3 
14 15 16 
................................ 
............... : ........ ...................... 1 2 3 4 
...................... 
...................... 
........................... 
............... 
.................... .................... 
.................................. 
......................................... 
.................... 
................... 
................... ,.j 
........................ 
.................. 
6 7 6 
. . ../ . . . ..P .A.... . . . . . . . 
I I I 19 20 21 22 
1 
6 : 
I 
L 
3 
7 
11 
c 
15 
21 
1 
6 
1 
12 
16 
i 22 
I I I I I I 
 .A: 1 
,.: :. .~..:.~:.:::.::::::::::::::,::::::::::.::::::::::::.:::, :.,.:.:.> 2 3 4 
. . . . . . .,.,...,.,.,.,.,.,... . . . . . . . . ..,...,... ,., .,. ., ,.,. 
. . . . . . . . . ./...:. . .I.\.... . . . . . . . . . . . . . . . . . . . ..I... y:.:.:.:.: 
::.::.::::-.:::::::::::::,:::::::::::::::::::::::,::::::::::::::.,.:.:.:.:.:. 
. . . . . . ..i............ . . ..\..............._ .A........ . . . . . . . . . . . . . 
. . . . . . . . . ,. ./ ., . . . . . .,. ,...,._.,.,.,.,.,._. ,.,.,.,.,., ._.,. ,.,.,.,.,., 
5 
6 7 a 
,::,.::.::..:..:: . . . . . . . . . . . . . . . . . . . 
. . . . . . ..I.... . . . . . . . ..i . . . . . . . . . . . ../........ . . . . . . ...\. . ../.. . 
.A.. . . . . . . . . . .A...... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 
.:ll.;.:;.x:;%i:-::. y, 2 : : y : x :l:::::::I:I:I:I:I:i:i::: 
10 11 12 
,. ..,.,... ,. .,. ,_, 
. . . . . ..A . . . . . . . . . . . . . . . . . . . . . . . . . . 
:-l,::!l:i:i:l:I:::::::::::::i::j:~:::~::.:~: ..:: 
.:.: ::: .I. .: . ...,.. . . ..I.... .,: ..; >>:.:.: :.,.:.... ::,:: .:::.: 
:.::.:.:.:.::.:.:...:.:.:.:.:.:.:.:... .,.,. .,.,., ,.,.,. .,., ,.,. , 3 
14 15 16 
::: :::::::::::::::::::::::::::.:::::::::.:::.::::::.:::::::::::, j:;: j:j:::; 
,_ ,_,.,.,.,.,.,.,. 
.,...,.,., ., ., ,., ,. 
.,..., ,. 
. . . . . . . . ...\. . ,. ,.,.,. 
. . . . . ./... . . . . . . . . . . .i :...\...... 
. .\......\..\... . . .A...... . . . . . . . . . . . . .., . . . . . . . . . 
.:.:.:...:.~:.:.:.:.:.:.: ::.:.:...:.:.:. 
>:...:.,... .: . . . ,. ,: :j::::. 
..:.:.:.:.:.:.:.:.:..:... ..:..v .:.:.>:.... T.: . . : . . . . . . . . . . 
17 16 19 
20 21 
22 
Multi Function = 1 
DSS/BLF= 1 XX (XX=Stations 1 O-25) 
CO Button= 2XX (XX=CO Lines 1-6) 
Loop Button= 3 
Pool Button = 4X (X=CO Line Group l-6) 
APPENDIX A-2 ISSUE 1, JANUARY 1991  
						

							sTARPLUS@ 616 FLEX 
KEY TELEPHONE SYSTEM 
P 
Line 
Grp 
Prog Code 11 
Prog i-6/ 
Button l-2 
co1 
co2 
co3 
co4 
co5 
*Ring Time-out 7 Line 
Type 
12 
1 
w 
j:::::::.:::::.::::::::::::: 
~~~I 
.:.:.:.:.:.:.:.:.:.:‘.::.:.: 
:::::::::::::j:::::::::::~:: 
ler is p 
Appendix A-3 CO Line Programming Chart 
Signal 
12 
2 
::::::::::::p:.:.:: >:.: 
;::::::::;:-::~:~:~:i:i:i: 
>J$fE 
:::::::::::::::::::::::::.:: 
gramr d only ONCE for all CC Nite Flash 
--l--- 
Ring Time1 
14 1 15 
I 
=I= 
. . . . . . . . ..:... . . . . . . . . . . . . ..,...........,.. . . . . . . . . 
.A\.. .:..::, 
Sag ;.~~~~‘:i;l;:l;:::~:;:;iii. 
gY-~:9: &:~~~ 
. . . 2.. 
. . . .,:.:.:.:.:.:.:. ..:.:.:.:.:.:.‘.:‘.~:.:.:.~~ 
-ines. Ring 
Detect 
16 
~~~~ 
..:.:.:.: 
@ggg$ 
:..::...  . . . ..I....... 
Dial 
Pulse 
17 
-II- 
ISSUE 1, JANUARY 1991 
APPENDIX A-3  
						

							sTARPLUS@ 616 FLEX KEY TELEPHONE SYSTEM 
Appendix A-4 System Programming Chart 
Prog 
Pw 
Button Code Feature Format Default New 
. . 
:.,.:::::::::.::;(:>,., ,::j: .‘.” .‘...‘.‘.‘.‘...‘. 
:,::::::~:.:,.::::::,,:: ..: .:y ,;,: .:jj:j:,‘jj::j::jij,,, 
1 21 CO Line Queuing Yes/No i::i:jji..:i~li~i’ceG--‘ii.-i:;~i:ii 
..j::: :.,:j:j.,:::::.:. . . . . ..j.j,j:j::. 1’. ‘;:$::I:’ : ‘;1:1; 
.;; . . ,. ,. 
.:. .: ::.:::::i:j:;: ,,,,. ..j ,.:,:,:, . . . . .,., .,. .::. 
2 21 Hold Preference System/Exclusive ~~I~~~~,~~ 
,. ~:.:.:.:::.:::.:: 
.:. . . .: ;;: ::::.,. ::,::::,::) 
::.,,. .::..:..:.: .., ..: .:::::::...: .:...: I:, j:j:: 
:::: :.,.: :.,.:.:.: 
3 21 Alarm Detection Open/Clo& ~~~~~~~~; 
.~ :.:.:.:... :j:;:j::::,: j:::j.j:j . . . ::::::::: 
.:.:.:.: :.:.:.,.:.:: 
.i:c,. :.::. ~ :..,.’ j::.:.i’:::‘:.j,jjj:~i:i:i:iiiiiiiii: 
4 21 Alarm Signaling 
Repeated/Single .ii::i;iliii;i:.ii:~~~~~~~~~~ 
j:::j:j:j:~::..:.~:::::::~:..‘.:.: :::.::: 
x.. . . . . . . . . . . . . . . . . . . 
. . . . . . . 
,:::::.y: .:. ‘:;:::;:;,;:;:::. ,.:,y::. . . . . . . . . . 
..: :>.,: .,.. :::::::, 
,,:..: .: .,.:.:.y y:. . ...;.:::: ,:::::: y:;:fi 
5 
21 Automatic Privacy 
Yeah .:“:“:‘::y~* 2;:;: :... ., j 
,.: :.:.. ::::::;; ,,.,. 
‘i;:& :::::::. ::. :::, :: ::.. 2:::: ,:,,:.,:.:.:::.,:. 1 
. . . 
. . . . . . . . . . . . . . . . . ,.,., .,... . . . . :..:. ..I 
6 21 Alarm Enable 
7 21 “,;c,“, pund Music 
B 
22 Exclusive Hold Recall 000-255 sec. 
:,:::;::::::::: :,.. :.:.:.: .A..,. :. 
2i 
NA 23 
24 
25 
26 
27 .,........:.: :....... . ,.... . ...: :.>: 
System Hold Recall 
()0@255 sec. ~~;~~~~ 
. . . . . . . >>:.:.: :...:.: . . . .,.,.,.,.,., 
.~,,:,,::,.,,,:,:: ::. >:...:..y.::::::: .::,:.y:::... . . . 
.,.... . . . . 
.,.:.:.: .:. . . . . . . . . . . . . . . . . . . ,. . . . . . . . . . . . . . . . 
. . . >..: :.:.:.: 
..:.:.:. F ,+:,:.. :.y..... :.:.:.::: :.,,: :j: 
Transfer Recall Timer 
(-J-)0-255 sec. ,il”‘i::;‘I”:‘63~~~~~~~ 
,..., .: 
.,. . .. :..:.:j:,.~:j::.‘. j:::j:::j:: .:::::I: 
,.. .: ,., : :...: ;.: : : : .,,. 
,,. .:.::::..;:; ::.;;;;jj 
.:.:..:.::‘::;.: :.:. ‘. ::j:j: ., ,.,;,. 
Message Reminder Tone 
00-99 min. :j:jj::,:.k:. ::z~~:~y,:jj,:l,::i:~~ ..iy’::  .“.““‘:yj~, +?.:.. .,: z: 
,.,, 
‘.X : .:.. ::. ,.:.:.....:.: . . 
Pause Timer ;:I:$ ‘. ‘,:~~~;:~~ 
l-9 sec. :>:: 
,. ,,: .: . . . . . . ..,.,.: .,.,.,. ‘.:.:. . . . . . . . 
;y.:: .“,:,j..::j:.::: :p.: .I,:, j::.. :..:.3..: 
Executive/Secretary 
l-4 28 Loud BelV 
CO Line Control 
1-4 31 PBX Codes 
NA 32 
33 
NA 34 

						

							sTARPLUS@ 616 FLEX KEY TELEPHONE SYSTEM 
Appendix A-5 System Speed Dial Chart 
Programmed at attendant station. 
Digits ‘up to 16) 
Bin 10 
Bin 11 
Bin 12 
Bin 13 
Bin 14 
Bin 15 
Bin 16 
Bin 17 
Bin 18 
Bin 19 
Bin 20 
Bin 21 
Bin 22 
Bin 23 
Bin 24 
Bin 25 
Bin 26 
Bin 27 
Bin 28 
Bin 29 1 Bin 30 1 
I 
1 Bin31 1 
1 Bin 32 1 
I Bin 33 
I 
1 Bin 35 1 
I 
1 Bin 36 1 
I 
I Bin 37 1 
Bin 38 
1 Bin 40 1 
I 
1 Bin 41 1 
I 
I Bin 42 I 
Bin 43 
Bin 44 
Bin 45 
Bin 46 
Bin 49 
ISSUE 1, JANUARY 1991 APPENDIX A-5  
						

							wARPLUS* 616 FLEX KEY TELEPHONE SYSTEM 
Appendix A-6 Exception Tables Programming Chart 
1 Coe.;(WowTableA ) 
BIN 3 
BIN 4 
BIN 5 
BIN 6 
BIN 7 
BIN 8 
1 BIN9 t 
BIN 10 
BIN 16 
1 Code 43 - Allow Table B 
I 
BIN 4 
BIN 5 
BIN 8 
, BIN9 
BIN 11 
BIN 12 
BIN 13 
BIN 14 
BIN 15 
BIN 16 BIN 14 
BIN 15 
BIN 16 
APPENDIX A-6 ISSUE 1, JANUARY 1991 
1-  
						

							sTARPLUS@ 616 FLEX KEY TELEPHONE SYSTEM 
APPENDIX B 
STARPLUS 616 FLEX PART NUMBERS 
SP61600-10 
SP61620-03 
SP61630-00 
SP61632-00 
VCSllOl 
SP6161 o-00 
SP6161 O-44 
SP6161 O-54 
SP6161 O-60 
SP61612-00 
SP61612-44 
SP61612-54 
SP61612-60 
SP61614-00 
SP61614-44 
SP61614-54 
SP61614-60 
SP61616-44 
SP61650-10 
SP61654-10 
SP61640-00 
SP61640-44 
SP61640-54 
SP61640-60 
SP61660-00 
SP61660-44 
SP61660-54 
SP61660-60 
SP61666-54 
SP61666-60 
Pl4108-54 
P14108-60 
SP61664-01 
SP61664-00 
SP61662-00 
SP61668-00 616 FLEX BASIC KSU 
PROGRAM MODULE III 
REAL TIME CLOCK UNIT (RCU) KIT 
SERIAL INTERFACE UNIT (SIU) KIT 
BATTERY BACKUP UNIT 
BASIC KEY TELEPHONE-BLACK 
BASIC KEY TELEPHONE-ASH 
BASIC KEY TELEPHONE-GRAY 
BASIC KEY TELEPHONE-BURGUNDY 
ENHANCED KEY TELEPHONE-BLACK 
ENHANCED KEY TELEPHONE-ASH 
ENHANCED KEY TELEPHONE-GRAY 
ENHANCED KEY TELEPHONE-BURGUNDY 
EXECUTIVE KEY TELEPHONE-BLACK 
EXECUTIVE KEY TELEPHONE-ASH 
EXECUTIVE KEY TELEPHONE-GRAY 
EXECUTIVE KEY TELEPHONE-BURGUNDY 
PHONE BOX-ASH 
STARPLUS 616 FLEX INSTALLATION MANUAL 
STARPLUS 616 FLEX STATION USER GUIDE 
WALL MOUNT KIT-BLACK 
WALL MOUNT KIT-ASH 
WALL MOUNT KIT-GRAY 
WALL MOUNT KIT-BURGUNDY 
REPLACEMENT HANDSET-BLACK 
REPLACEMENT HANDSET-ASH 
REPLACEMENT HANDSET-GRAY 
REPLACEMENT HANDSET-BURGUNDY 
12 FOOT HANDSET CORD-GRAY 
12 FOOT HANDSET CORD-BURGUNDY 
25 FOOT HANDSET CORD-GRAY 
25 FOOT HANDSET CORD-BURGUNDY 
DIRECTORY SHEET FOR BASIC KEY TELEPHONE 
BLANK DESIGNATION TABS FOR STARPLUS TELEPHONES 
BUlTON CAPS (1 RED, 9 CLEAR) 
DIRECTORY WINDOW FOR BASIC KEY TELEPHONE 
ISSUE 1, JANUARY 1991 APPENDIX B-1